2000 Volvo S80 Recalls

---

NHTSA Campaign Number: 10V566000
Manufacturer: Volvo Car USA LLC
Manufacturer Campaign Number: R231
Date of Owner Notification: November 18th, 2010

Defect Summary:
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence Summary:
AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Corrective Summary:
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Recall Notes:
VOLVO SAFETY RECALL NO. R231.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 07E023000
Manufacturer: Volvo Car USA LLC
Date of Owner Notification: April 2nd, 2007

Defect Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Consequence Summary:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Corrective Summary:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CARDONE MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 06V441000
Manufacturer: Volvo Car USA LLC
Manufacturer Campaign Number: R155
Manufactured Begin Date: May 11th, 1998
Manufactured End Date: August 27th, 2001
Date of Owner Notification: December 29th, 2006

Defect Summary:
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Consequence Summary:
THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.

Corrective Summary:
DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Recall Notes:
VOLVO RECALL NO. R155. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 04V451000
Manufacturer: Volvo Car USA LLC
Manufacturer Campaign Number: 141
Manufactured Begin Date: May 6th, 1998
Manufactured End Date: May 15th, 2000
Date of Owner Notification: November 29th, 2004

Defect Summary:
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

Consequence Summary:
A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.

Corrective Summary:
DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

Recall Notes:
VOLVO RECALL NO. 141.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 00V238000
Manufacturer: Volvo Car USA LLC
Manufacturer Campaign Number: 99
Manufactured Begin Date: April 1st, 1998
Manufactured End Date: December 31st, 1999
Date of Owner Notification: September 18th, 2000

Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.

Consequence Summary:
THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.

Corrective Summary:
DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.

Recall Notes:
VOLVO RECALL NO. 99.OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).