1995 Volvo Acl Recalls

---

NHTSA Campaign Number: 98V255000
Manufacturer: VOLVO TRUCKS NORTH AMERICA
Manufactured Begin Date: October 1st, 1986
Manufactured End Date: July 13th, 1998
Date of Owner Notification: November 27th, 1998

Defect Summary:
VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE 'B' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES.

Consequence Summary:
THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES.

Corrective Summary:
DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE.

Recall Notes:
OWNER NOTIFICATION BEGAN DURING NOVEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 96V157000
Manufacturer: VOLVO TRUCKS NORTH AMERICA
Manufactured Begin Date: May 26th, 1995
Manufactured End Date: August 11th, 1995
Date of Owner Notification: September 4th, 1996

Defect Summary:
THE REAR MOST AXLE OF THE TANDEM AXLE SET COULD HAVE INOPERABLE BRAKES ON ONE OR BOTH WHEELS BECAUSE THE BRAKE S-CAM WAS INCORRECTLY INSTALLED.

Consequence Summary:
THIS CONDITION COULD CAUSE INCREASED STOPPING DISTANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Corrective Summary:
DEALERS WILL INSPECT THE BRAKE SYSTEM AND REPAIR THE S-CAM ASSEMBLY IF FOUND REVERSED.

Recall Notes:
OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO GM HEAVY DUTY TRUCK AT 1-800-528-6586.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 96V095000
Manufacturer: VOLVO TRUCKS NORTH AMERICA
Manufactured Begin Date: August 1st, 1994
Manufactured End Date: February 1st, 1996
Date of Owner Notification: April 23rd, 1996

Defect Summary:
THE TRACTION SOLENOID EXHAUST CAN BE OBSTRUCTED DUE TO INADEQUATE DRAINAGE AND A BUILD-UP OF ROAD CONTAMINATION BETWEEN THE MOUNTING BRACKET AND THE SOLENOID HOUSING. THE OBSTRUCTED EXHAUST PREVENTS THE RELAY VALVE CONTROL AIR PRESSURE FROM VENTING AFTER A DIFFERENTIAL BRAKING TRACTION EVENT.

Consequence Summary:
THIS CONDITION WOULD KEEP THE REAR AXLE SERVICE BRAKES APPLIED WITHOUT ANY BRAKE PEDAL MOVEMENT BY THE DRIVER INCREASING THE RISK OF A VEHICLE ACCIDENT.

Corrective Summary:
DEALERS WILL REMOVE THE SUSPECT VALVE AND INSTALL A NEW VALVE THAT HAS A MODIFIED SOLENOID HOUSING WHICH WILL ALLOW FOR SUFFICIENT DRAINAGE AND A NEW VALVE MOUNTING BRACKET WITH INCREASED HEIGHT TO REDUCE ENTRY OF CONTAMINATION.

Recall Notes:
SYSTEM: BRAKES; AIR SYSTEMS. VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS EQUIPPED WITH A BENDIX ATR TRACTION RELAY VALVE. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT VOLVO GM HEAVY TRUCK AT 1-800-528-6586. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 96V032000
Manufacturer: VOLVO TRUCKS NORTH AMERICA
Manufactured Begin Date: June 1st, 1995
Manufactured End Date: December 1st, 1995
Date of Owner Notification: February 13th, 1996

Defect Summary:
THE REAR SUSPENSION AXLE RETENTION PLATE CAN BREAK UNDER NORMAL USE, AFFECTING AXLE ALIGNMENT.

Consequence Summary:
THIS CONDITION COULD RESULT IN LOSS OF REAR AXLE STABILITY AFFECTING VEHICLE DIRECTIONAL CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Corrective Summary:
DEALERS WILL REMOVE AND REPLACE THE AXLE RETENTION CLIP PLATES ON AFFECTED VEHICLES.

Recall Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR; AIR SUSPENSION. VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT VOLVO GM HEAVY TRUCK AT 1-800-528-6586. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V218000
Manufacturer: VOLVO TRUCKS NORTH AMERICA
Manufactured Begin Date: June 1st, 1994
Manufactured End Date: October 1st, 1995
Date of Owner Notification: January 17th, 1995

Defect Summary:
UNDERCOATING APPLIED TO THE INSIDE OF THE CAB SHELL SQUEEZED OUT DURING ASSEMBLY ONTO THE BRAKE PEDAL PLUNGER.

Consequence Summary:
UNDERCOATING ON THE PLUNGER MAY CAUSE THE PLUNGER TO STICK RESULTING IN INCREASED BRAKE PEDAL EFFORT AND/OR SLOW RELEASE OF THE BRAKES INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Corrective Summary:
DEALERS WILL CLEAN THE UNDERCOATING FROM THE BRAKE PEDAL PLUNGER ASSEMBLY, LUBRICATE AND REINSTALL THE BRAKE PEDAL PLUNGER ASSEMBLY.

Recall Notes:
SYSTEM: BRAKES; AIR; PEDALS; LINKAGES AND VALVES.VEHICLE DESCRIPTION: HEAVY DUTY CLASS 8 TRUCKS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO GM HEAVY TRUCK AT 1-800-528-6586. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.