2004 Thomas Er Recalls

---

NHTSA Campaign Number: 08V622000
Manufacturer: THOMAS BUILT BUSES, INC.
Manufacturer Campaign Number: FL-539
Manufactured Begin Date: February 1st, 2002
Manufactured End Date: October 17th, 2008
Date of Owner Notification: July 6th, 2009

Defect Summary:
DAIMLER TRUCKS IS RECALLING 18,198 MY 2003-2009 THOMAS BUILT ER, MVP-ER, HDX, AND MVP-EF SCHOOL AND TRANSIT BUSES EQUIPPED WITH A DUAL POWER SWITCH AND MANUFACTURED FROM FEBRUARY 1, 2002 THROUGH OCTOBER 17, 2008. SOLID STATE CIRCUIT BREAKERS MAY TRIP UNNECESSARILY POTENTIALLY RESULTING IN A LOSS OF POWER TO THE BUS CHASSIS AND BODY ELECTRICAL CIRCUITS CAUSING AN UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING.

Consequence Summary:
UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING COULD RESULT IN A VEHICLE CRASH.

Corrective Summary:
THOMAS BUILT BUS DEALERS WILL REPLACE THE SOLID STATE DUAL POWER SWITCH WITH A MECHANICAL CIRCUIT PRODUCTION (MEGA FUSE). THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

Recall Notes:
DAIMLER TRUCK RECALL NO. FL-539.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 08V087000
Manufacturer: THOMAS BUILT BUSES, INC.
Manufacturer Campaign Number: FL-525
Manufactured Begin Date: January 1st, 1994
Manufactured End Date: March 10th, 2008
Date of Owner Notification: August 18th, 2008

Defect Summary:
DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.

Consequence Summary:
IN THE EVENT OF AN EMERGENCY, A PERSON ON THE OUTSIDE OF THE BUS MAY BREAK THE DOOR HANDLE TRYING TO OPEN THE EMERGENCY EXIT POTENTIALLY DELAYING EVACUATION AND INCREASING THE RISK OF PERSONAL INJURY TO THE VEHICLE'S OCCUPANTS.

Corrective Summary:
DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

Recall Notes:
DAIMLER TRUCKS RECALL NO. FL-525.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 07V544000
Manufacturer: THOMAS BUILT BUSES, INC.
Manufacturer Campaign Number: FL-516
Manufactured Begin Date: October 23rd, 2000
Manufactured End Date: January 24th, 2006
Date of Owner Notification: March 28th, 2008

Defect Summary:
CERTAIN 2001 THROUGH 2008 THOMAS BUILT FS-56, ER, MVP ER, HDX, AND MVP EF SCHOOL BUSES MANUFACTURED FROM OCTOBER 23, 2000, THROUGH JANUARY 24, 2006, EQUIPPED WITH TYCO PC BOARD AND TYPE II AUTO RESET CIRCUIT BREAKERS. TYPE II AUTO RESET CIRCUIT BREAKER TEMPERATURES MAY EXCEED THE RATING OF THE TYCO PC BOARD CAUSING THE BOARDS TO MELT POTENTIALLY RESULTING IN A VEHICLE FIRE.

Consequence Summary:
A VEHICLE FIRE CAN OCCUR POSSIBLY RESULTING IN A CRASH.

Corrective Summary:
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY REPLACING THE TYPE II AUTO RESET CIRCUIT BREAKERS WITH MANUAL CIRCUIT BREAKERS, AND THE JUMPER CABLE. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT THOMAS BUILT CUSTOMER SUPPORT OFFICE AT 336-889-4871.

Recall Notes:
FREIGHTLINER RECALL NO. FL-516.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V347000
Manufacturer: THOMAS BUILT BUSES, INC.
Manufacturer Campaign Number: FL-454
Manufactured Begin Date: January 8th, 2002
Manufactured End Date: March 8th, 2005
Date of Owner Notification: September 14th, 2005

Defect Summary:
CERTAIN 2002-2005 MY THOMAS BUILT MINOTOUR, CONVENTIONAL, MVP-ER, ER, HDX, AND MVP-EF MODEL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 8, 2002, AND MARCH 8, 2005, EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence Summary:
SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Corrective Summary:
FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, THOMAS BUILT IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, DEALERS WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, THOMAS BUILT WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE RECALL BEGAN ON SEPTEMBER 14, 2005. OWNERS MAY CONTACT THOMAS BUILT'S CUSTOMER SUPPORT OFFICE AT 336-889-4871.

Recall Notes:
THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT.FREIGHTLINER/THOMAS BUILT RECALL NO. FL-454.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V340000
Manufacturer: THOMAS BUILT BUSES, INC.
Manufacturer Campaign Number: FL-454
Manufactured Begin Date: January 8th, 2002
Manufactured End Date: March 8th, 2005
Date of Owner Notification: September 14th, 2005

Defect Summary:
CERTAIN 2002-2005 MY THOMAS BUILT MINOTOUR, CONVENTIONAL, MVP-ER, ER, HDX, AND MVP-EF MODEL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 8, 2002, AND MARCH 8, 2005, EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence Summary:
SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Corrective Summary:
THOMAS BUILT WILL NOTIFY ITS OWNERS AND REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2005. OWNERS MAY CONTACT THOMAS BUILT'S CUSTOMER SUPPORT OFFICE AT 336-889-4871.

Recall Notes:
FREIGHTLINER/THOMAS BUILT RECALL NO. FL-454.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V208000
Manufacturer: THOMAS BUILT BUSES, INC.
Manufacturer Campaign Number: FL-450
Manufactured Begin Date: November 1st, 2002
Manufactured End Date: February 28th, 2005

Defect Summary:
CERTAIN MY 2002-2005 THOMAS BUILT SAF-T-LINER ER SCHOOL BUSES AND ER TRANSIT BUSES MANUFACTURED BETWEEN NOVEMBER 2002 AND FEBRUARY 2005 AND EQUIPPED WITH JOHN DEERE 8.1L COMPRESSED NATURAL GAS ENGINES MODELS HFN01 AND HFN03. THE ENGINE CONTROL UNIT AND THROTTLE CAN UNEXPECTEDLY SURGE. THESE UNITS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, ACCELERATOR CONTROL SYSTEMS.

Consequence Summary:
A SUDDEN ENGINE SURGE COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Corrective Summary:
JOHN DEERE WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER/THOMAS BUILT AND WILL UPDATE THE ENGINE CONTROL UNIT SOFTWARE FREE OF CHARGE. OWNERS MAY CONTACT JOHN DEERE AT 1-800-JD-ENGINE.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.