2008 Pierce Velocity Recalls

---

NHTSA Campaign Number: 13V214000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 74B242
Manufactured Begin Date: June 6th, 2007
Manufactured End Date: May 17th, 2013
Date of Owner Notification: June 28th, 2013

Defect Summary:
Pierce Manufacturing Inc. (Pierce) is recalling certain model year 2007-2013 Velocity, Impel, and Dash CF emergency vehicles manufactured June 6, 2007, through May 31, 2013. The springs in the outer door handles are not of sufficient stiffness to prevent inadvertent door opening in certain impacts. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 206, "Door Locks and Door Retention Components."

Consequence Summary:
In the event of a crash, the weak springs may allow the door to open and possibly fail to contain emergency personnel or equipment, increasing the risk of injury.

Corrective Summary:
Pierce will notify owners, and dealers will replace the door handle spring with a stiffer one, free of charge. Owners may contact Pierce at 1-920-832-3000. The recall began on June 28, 2013. Pierce's recall number is 74B242.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 13V062000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 74B237
Manufactured Begin Date: June 6th, 2007
Manufactured End Date: October 30th, 2010
Date of Owner Notification: May 1st, 2013

Defect Summary:
Pierce is recalling certain model year 2007-2010 Velocity and Impel fire trucks manufactured from June 6, 2007, through October 30, 2010. The springs inside the inner door handles may allow the door to open inadvertently.

Consequence Summary:
If the door inadvertently opens while the vehicle is in motion, the occupants may fall out and suffer personal injury.

Corrective Summary:
Pierce will notify owners, and dealers will replace the inner door handles, free of charge. The recall began during May 2013. Owners may contact Pierce at 1-920-832-3000.

Recall Notes:
Pierce's campaign recall number is 74B237.Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 11V527000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 74B226
Manufactured Begin Date: December 19th, 2007
Manufactured End Date: October 7th, 2011
Date of Owner Notification: December 16th, 2011

Defect Summary:
PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2007-2011 ARROW XTAND VELOCITY, MODEL YEAR 2008-2011 CUSTOM CONTENDER, IMPEL, QUANTUM AND MODEL YEAR 2009-2011 SABER EMERGENCY TRUCKS, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM DECEMBER 19, 2007, THROUGH OCTOBER 7, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

Consequence Summary:
IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.

Corrective Summary:
PIERCE IS WORKING WITH MERITOR WABCO AND WILL REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT MERITOR WABCO AT 1-248-435-8001 OR PIERCE AT 1-920-832-3000.

Recall Notes:
THE NHTSA NUMBER ASSIGNED TO THE MERITOR WABCO'S RECALL IS 11E-039.PIERCE'S SAFETY RECALL NUMBER IS 74B226.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V423000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 74B207
Manufactured Begin Date: May 30th, 1998
Manufactured End Date: November 25th, 2008
Date of Owner Notification: October 12th, 2010

Defect Summary:
PIERCE IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2008 ARROW XT, LANCE, VELOCITY, ENFORCER, IMPEL, AND DASH CUSTOM FIRE APPARATUS VEHICLES MANUFACTURED FROM MAY 30, 1998 THROUGH NOVEMBER 25, 2008. THE STEERING GEAR BRACKET MAY FRACTURE AND BREAK. IF THIS OCCURS THE STEERING GEAR MAY DETACH FROM THE VEHICLE.

Consequence Summary:
DETACHMENT OF THE STEERING GEAR WILL RESULT IN A LOSS OF STEERING CONTROL THAT COULD CAUSE A CRASH.

Corrective Summary:
PIERCE WILL NOTIFY OWNERS AND DEALERS WILL INSTALL A NEW STEERING GEAR MOUNTING BRACKET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 12, 2010. OWNERS ARE BEING INSTRUCTED TO INSPECT THE STEERING GEAR BRACKET PRIOR TO EACH TRIP. THE REMEDY TO REPAIR THIS DEFECT IS EXPECTED TO BEGIN NO EARLIER THE JANUARY 31, 2011. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.

Recall Notes:
PIERCE SAFETY RECALL NO. 74B207.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V317000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Date of Owner Notification: July 1st, 2010

Defect Summary:
PIERCE IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ARROW XT, DASH, ENFORCER, IMPEL, QUANTUM, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM OCTOBER 11, 2006 THROUGH JUNE 16, 2010 AND EQUIPPED WITH MERITOR WABCO EX225 REAR DISC BRAKES AND ONSPOT AUTOMATIC TIRE CHAINS. THE MERITOR WABCO EX225 REAR DISC BRAKE CALIPER MAY INTERFERE WITH THE ONSPOT AUTOMATIC TIRE CHAIN BRACKETS. THIS INTERFERENCE MAY RESTRICT THE CALIPER FROM FULL MOVEMENT.

Consequence Summary:
IF THIS INTERFERENCE OCCURS, BRAKING PERFORMANCE MAY BE REDUCED WITHOUT WARNING AND A CRASH MAY OCCUR.

Corrective Summary:
DEALERS WILL INSTALL NEW AUTOMATIC TIRE CHAIN BRACKETS. THE NEW BRACKETS PROVIDE ADDITIONAL CLEARANCE FOR THE FULL ACTUATION OF THE DISC BRAKE CALIPERS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN IN JULY 2010. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Recall Notes:
PIERCE SAFETY RECALL NO. 39-0139830. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V300000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Manufactured Begin Date: February 20th, 2003
Manufactured End Date: March 27th, 2009
Date of Owner Notification: October 4th, 2010

Defect Summary:
PIERCE IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2009 CUSTOM CONTENDER, DASH, ENFORCER, IMPEL, LANCE SABER, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM FEBRUARY 20, 2003, THROUGH MARCH 27, 2009. THESE TRUCKS MAY BE EQUIPPED WITH DROP-DOWN FIRE HOSE TRAYS MOUNTED UNDER THE FRONT BUMPER. THE HOSE TRAY LATCH MAY ACCIDENTALLY OPEN WHILE THE VEHICLE IS IN MOTION.

Consequence Summary:
IF THIS OCCURS THE FIRE HOSE MAY DROP TO THE ROADWAY WITHOUT WARNING. POTENTIAL INJURY TO PEOPLE AND PROPERTY MAY OCCUR. THE SUDDEN HOSE DEPLOYMENT MAY ALSO DISTRACT DRIVERS TRYING TO AVOID THE HOSE AND A CRASH MAY OCCUR.

Corrective Summary:
A NEW AND IMPROVED LATCH DESIGN HAS BEEN DEVELOPED AND A NEW HOSE BOX INCORPORATING THE NEW LATCH WILL BE INSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 4, 2010. OWNER MAY CONTACT PIERCE AT 1-920-832-3000.

Recall Notes:
PIERCE SAFETY RECALL NO. 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V195000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Manufactured Begin Date: December 20th, 2006
Manufactured End Date: February 1st, 2010
Date of Owner Notification: May 28th, 2010

Defect Summary:
PIERCE IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ARROW XT, DASH, LANCE, QUANTUM, AND VELOCITY EMERGENCY VEHICLES MANUFACTURED FROM DECEMBER 20, 2006, THROUGH FEBRUARY 1, 2010, EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES. THE ENGINE MAY SHUT DOWN UNEXPECTEDLY WHEN A DIESEL PARTICULATE FILTER OVER TEMPERATURE CONDITION IS DETECTED.

Consequence Summary:
UNEXPECTED EMERGENCY VEHICLE ENGINE SHUTDOWN UNDER CERTAIN CONDITIONS COULD HAMPER RESCUE OPERATIONS AND PLACE THE PUBLIC AT RISK.

Corrective Summary:
OWNERS WILL BE NOTIFIED BY DETROIT DIESEL AND DETROIT DIESEL WILL REPAIR THE VEHICLES FREE OF CHARGE BY REPROGRAMMING THE ENGINE CONTROL LOGIC TO ILLUMINATE A MALFUNCTION INDICATOR LIGHT WITHOUT REQUESTING ENGINE SHUTDOWN. PLEASE SEE DAIMLER TRUCKS' DEFECT REPORT 10E-005. THE SAFETY RECALL BEGAN ON MAY 28, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR PIERCE AT 1-920-832-3000.

Recall Notes:
PIERCE'S RECALL CAMPAIGN NUMBER IS 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V389000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Manufactured Begin Date: April 1st, 2008
Manufactured End Date: September 30th, 2009
Date of Owner Notification: September 4th, 2009

Defect Summary:
PIERCE IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 FIRE TRUCKS MANUFACTURED BETWEEN APRIL 1, 2008 AND SEPTEMBER 30, 2009, EQUIPPED WITH CUMMINS ISB CM2150, ISC CM2150, ISL CM2150, ISM CM876, AND ISX CM871 MODEL DIESEL ENGINES. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO INHIBIT AFTERTREATMENT DIESEL PARTICULATE FILTER REGENERATION IN ENVIRONMENTS WHERE THE OPERATOR BELIEVES IT MAY BE UNSAFE FOR ELEVATED EXHAUST TEMPERATURES. DUE TO AN ISSUE WITH THE LOGIC IN THE ECM SOFTWARE IN THESE ENGINES, THE SWITCH MAY NOT FUNCTION CORRECTLY, LEADING THE OPERATOR TO BELIEVE THAT THE SWITCH IS IN "INHIBIT" MODE WHEN IT IS NOT.

Consequence Summary:
THIS CONDITION WILL PERMIT HOT EXHAUST GASES TO EXIT THE VEHICLE TAILPIPE, INCREASING THE RISK OF MELTING OR BURNING OF NEARBY SURFACES, OR A FIRE.

Corrective Summary:
PIERCE IS WORKING WITH CUMMINS TO REPAIR THE ENGINES. CUMMINS IS CONDUCTING THIS CAMPAIGN AND WILL PROVIDE THE REMEDY FREE OF CHARGE. PLEASE SEE CUMMINS RECALL CAMPAIGN 09E-046. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2009. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS (1-800-343-7357) OR PIERCE AT 1-920-832-3000.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V341000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Manufactured Begin Date: December 5th, 2007
Manufactured End Date: July 15th, 2009
Date of Owner Notification: August 31st, 2009

Defect Summary:
PIERCE IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 FIRE TRUCKS EQUIPPED WITH SIDE-ROLL PROTECTION SYSTEMS. THE SENSOR DESIGNED TO DETECT VEHICLE ROLL CAN MALFUNCTION RESULTING IN AN INADVERTENT DEPLOYMENT OF THE PROTECTION SYSTEM.

Consequence Summary:
INADVERTENT DEPLOYMENT OF THE SIDE-ROLL PROTECTION SYSTEM COULD RESULT IN A VEHICLE CRASH OR INJURY TO AN OUT OF POSITION OCCUPANT.

Corrective Summary:
PIERCE WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 31, 2009. OWNERS MAY CONTACT PIERCE TOLL-FREE AT 1-888-974-3723.

Recall Notes:
PIERCE'S RECALL CAMPAIGN NUMBER 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V203000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Manufactured Begin Date: January 1st, 2008
Manufactured End Date: May 31st, 2009
Date of Owner Notification: July 2nd, 2009

Defect Summary:
PIERCE IS RECALLING 185 MODEL YEAR 2008 AND 2009 CUSTOM FIRE TRUCKS MANUFACTURED BETWEEN JANUARY 1, 2008 AND MAY 31, 2009, EQUIPPED WITH MERITOR WABCO STEERING ANGLE SENSORS (SAS). INTERNAL FRICTION CAN DEVELOP BETWEEN THE SENSOR GEARS AND THE SENSOR HOUSING AS A RESULT OF EXTERNAL FORCES EXPERIENCED ON THE VEHICLE INCLUDING VIBRATION. IF DEVELOPED FRICTION IS GREAT ENOUGH, THE DRIVING TAB OF THE SAS CAN SHEAR AS THE DRIVER TURNS THE STEERING WHEEL.

Consequence Summary:
WITH A BROKEN SAS DRIVING TAB, THE ELECTRONIC STABILITY CONTROL (ESC) WILL NOT FUNCTION PROPERLY, WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Corrective Summary:
PIERCE WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 2, 2009. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V137000
Manufacturer: PIERCE MANUFACTURING
Manufacturer Campaign Number: 39-0139830
Manufactured Begin Date: June 1st, 2008
Manufactured End Date: October 31st, 2008
Date of Owner Notification: May 4th, 2009

Defect Summary:
PIERCE MANUFACTURING IS RECALLING 257 MY 2008 EMERGENCY VEHICLES MANUFACTURED BETWEEN JUNE 1 AND OCTOBER 31, 2008, EQUIPPED WITH TRIMARK DOOR LATCHES. THESE LATCHES FAIL TO COMPLY WITH THE TRANSVERSE PULL STATIC LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." THE LATCHES MAY "POP" INTO THE SECONDARY LOCKING POSITION.

Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE DOOR WOULD NOT HAVE PRIMARY CLOSING SECURITY WHICH COULD POSSIBLY LEAD TO INJURY OF THE VEHICLE OCCUPANT.

Corrective Summary:
PIERCE WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT PIERCE CUSTOMER SERVICE TOLL-FREE AT 1-888-974-3723.

Recall Notes:
PIERCE'S RECALL NO. 39-0139830.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V105000
Manufacturer: PIERCE MANUFACTURING
Manufactured Begin Date: April 11th, 2007
Manufactured End Date: February 14th, 2008
Date of Owner Notification: April 7th, 2009

Defect Summary:
PIERCE IS RECALLING 167 MY 2007-2008 VELOCITY AND IMPEL FIRE TRUCKS. A BATTERY BOX IS POSITIONED ON BOTH SIDES OF THE CHASSIS FRAME DIRECTLY UNDER THE CAB. CAB INTERFERENCE MAY OCCUR WITH THE POSITIVE BATTERY POST AND THE ALUMINUM CAB FLOOR SUBSTRUCTURE.

Consequence Summary:
IF METAL-TO-METAL CONTACT WERE TO HAPPEN, AN ELECTRICAL ARCING BETWEEN THE CAB AND BATTERY COULD OCCUR INCREASING THE RISK OF ELECTRICAL SHORT CIRCUIT AND A FIRE.

Corrective Summary:
OWNERS WILL RECEIVE A REMEDY KIT ALONG WITH INSTRUCTIONS AND SHOULD INSPECT THE POSITIVE BATTERY POSTS TO MAKE SURE THE PROTECTIVE CAPS HAVE NOT WORN AWAY, IF CONTACT WITH THE CAB HAS OCCURRED, REPLACE THE BATTERY POST PROTECTIVE CAPS. THIS REMEDY WILL BE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 6, 2009. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 08V598000
Manufacturer: PIERCE MANUFACTURING
Manufactured Begin Date: April 17th, 2007
Manufactured End Date: April 25th, 2008
Date of Owner Notification: November 10th, 2008

Defect Summary:
PIERCE IS RECALLING 15 MY 2007-2008 DASH, ENFORCER, IMPEL, QUANTUM AND VELOCITY FIRE TRUCKS EQUIPPED WITH ARVINMERITOR REAR DISC BRAKES AND HENDRICKSON FIREMAAX SUSPENSION. INTERFERENCE WITH THE BRAKE CALIPER ADJUSTER BOLT SLEEVE AND THE SUSPENSION BEAM MAY OCCUR. THIS INTERFERENCE MAY OCCUR IF THE RIGHT HAND AND LEFT HAND BRAKE COMPONENTS WERE ASSEMBLED ON THE WRONG SIDE OF THE AXLE. THE ADJUSTER BOLT IS DESIGNED TO ROTATE AS THE BRAKE PADS WEAR. IF THE SLEEVE BECOMES DAMAGED, THE SLEEVE MAY PREVENT THE ADJUSTER FROM ROTATING.

Consequence Summary:
IF THE ADJUSTER CAN NOT ROTATE, BRAKE PERFORMANCE MAY BE COMPROMISED AND A CRASH MAY OCCUR.

Corrective Summary:
DEALERS WILL ADJUST THE BOLT SLEEVE AND THE PROPER COMPONENTS FREE OF CHARGE. ALL OWNERS HAVE BEEN NOTIFIED BY ARVINMERITOR.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 08V574000
Manufacturer: PIERCE MANUFACTURING
Manufactured Begin Date: June 1st, 2007
Manufactured End Date: October 24th, 2008
Date of Owner Notification: January 7th, 2009

Defect Summary:
PIERCE IS RECALLING 76 MY 2007-2008 ARROW XT AND VELOCITY FIRE TRUCKS EQUIPPED WITH CATERPILLAR C13 DIESEL ENGINES. THE EXTENSION PIPES ATTACHED TO THE AFTERTREATMENT REGENERATION DEVICE (ARD) MAY DEVELOP A HOLE, AND HEAT AND FLAME MAY ESCAPE DURING A REGENERATION OF THE DIESEL PARTICULATE FILTER.

Consequence Summary:
THIS MAY RESULT IN A FIRE HAZARD.

Corrective Summary:
PIERCE IS WORKING WITH CATERPILLAR TO REPAIR THESE VEHICLES (PLEASE SEE 08E054). OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986 OR PIERCE AT 1-920-832-3000.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.