1998 Orion Ii Recalls

---

NHTSA Campaign Number: 10V015000
Manufacturer: Daimler Buses North America
Manufactured Begin Date: February 1st, 1992
Manufactured End Date: May 31st, 2009
Date of Owner Notification: April 1st, 2010

Defect Summary:
DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.

Consequence Summary:
THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.

Corrective Summary:
DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 05V079000
Manufacturer: DAIMLER COMMERCIAL BUSES NA

Defect Summary:
ON CERTAIN TRANSIT BUSES, THE FUEL LIFT PUMP COULD FAIL IN A MANNER WHICH RESULTS IN ENGINE FUEL STARVATION, WHICH COULD RESULT IN A STALL CONDITION. POTENTIAL LIFT PUMP FAILURE MODES INCLUDE: BRUSH WEAR OUT, BUSHING FAILURE, ROTOR TAB INSERT FAILURE, OR ANY OTHER FAILURE MODE THAT WOULD CAUSE THE FUEL PUMPING ELEMENT TO STOP SPINNING.

Consequence Summary:
IF THE FUEL LIFT PUMP PUMPING ELEMENT STOPS SPINNING AND THE FUEL PUMPING VANES STOP IN A LOCATION WHICH BLOCKS FUEL FLOW THROUGH THE LIFT PUMP, THE ENGINE WILL BE STARVED OF FUEL. FUEL STARVATION COULD CAUSE LOW ENGINE POWER, ENGINE MISFIRE, OR ENGINE STALL. PRIOR TO THE ENGINE STALLING, THE OPERATOR COULD EXPERIENCE LOW ENGINE POWER, ENGINE MISFIRE, AND/OR DASH-MOUNTED FAULT LAMP ILLUMINATION.

Corrective Summary:
CUMMINS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR ORION BUS AT 905-403-7807.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 03V120000
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufactured Begin Date: January 1st, 1995
Manufactured End Date: December 31st, 2002
Date of Owner Notification: June 2nd, 2003

Defect Summary:
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.

Consequence Summary:
IN THE EVENT OF A CRASH, AN OCCUPANT MAY HAVE DIFFICULTY OPENING THE EMERGENCY EXIT WINDOW, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.

Corrective Summary:
DEALERS WILL REPAIR THESE WINDOWS. OWNER NOTIFICATION BEGAN JUNE 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-800-492-2116.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V033005
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufactured Begin Date: December 1st, 1998
Manufactured End Date: January 1st, 2000

Defect Summary:
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.

Consequence Summary:
WITHOUT FUSING, THE EQUALIZER MAY MELT, BURN, OR SMOKE, POSSIBLY RESULTING IN A FIRE OR A SMOKE FILLED BUS, THUS NECESSITATING A PASSENGER EVACUATION OF THE BUS. THE FAILURE MODE CAN CAUSE OPERATOR DISTRACTION, AND/OR POSSIBLE PERSONAL INJURY.

Corrective Summary:
ORION WILL NOTIFY OWNERS TO INSPECT THEIR BUSES FOR CERTAIN EQUALIZERS BY THE DATE CODE. THE AFFECTED EQUALIZERS WILL BE REPLACED BY VANNER. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VANNER AT 1-800-227-6937.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 98V189000
Manufacturer: DAIMLER COMMERCIAL BUSES NA
Manufactured Begin Date: May 12th, 1997
Manufactured End Date: June 2nd, 1998
Date of Owner Notification: August 21st, 1998

Defect Summary:
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH CHALLENGER 2000 MODEL 170 SERIES ALTERNATORS. THE POSITIVE POWER STUD MAY NOT BE PROPERLY SEATED IN PLACE CAUSING A LOOSE CONNECTION. THIS LOOSE CONNECTION CAUSES AN OVER-HEAT CONDITION WHEN THE ALTERNATOR IS UNDER A LOAD. ALSO THE MATERIAL USED TO INSULATE THE POWER STUD FROM THE RECTIFIER CAN TEAR AND CAUSE THE POSITIVE POWER STUD TO GROUND TO THE ALTERNATOR CASE.

Consequence Summary:
THE ALTERNATOR CAN GET HOT ENOUGH TO CATCH FIRE WHICH COULD SPREAD TO OTHER AREAS OF THE VEHICLE.

Corrective Summary:
DEALERS WILL REPLACE THESE ALTERNATORS.

Recall Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORTH POWER LLC AT 1-716-492-2278 OR ORION BUS AT 1-905-403-1111.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).