2004 Mid Bus Guide Recalls

---

NHTSA Campaign Number: 07V211000
Manufacturer: MID BUS CORPORATION
Date of Owner Notification: June 13th, 2007

Defect Summary:
CERTAIN MID BUS GUIDE AND GUIDE XL SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 3, 2003, AND MARCH 30, 2007. THE 39" AND 45" LEFT HAND BARRIERS FAIL TO CONFORM TO THE ENERGY ABSORPTION REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

Consequence Summary:
THE PURPOSE OF THIS STANDARD IS TO REDUCE THE NUMBER OF DEATHS AND THE SEVERITY OF INJURIES THAT RESULT FROM THE IMPACT OF SCHOOL BUS OCCUPANTS AGAINST STRUCTURES WITHIN THE VEHICLE DURING CRASHES AND SUDDEN MANEUVERS.

Corrective Summary:
MID BUS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2007. OWNERS MAY CONTACT MID BUS CUSTOMER SERVICE AT 1-877-358-6055.

Recall Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 06V374000
Manufacturer: MID BUS CORPORATION
Manufactured Begin Date: January 1st, 2002
Manufactured End Date: May 16th, 2006
Date of Owner Notification: October 30th, 2006

Defect Summary:
CERTAIN MY 2001 THROUGH 2006 MID BUS GUIDE SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1, 2002, AND MAY 16, 2006, EQUIPPED WITH COLLINS 3 PASSENGER SEATS, FREEDMAN ACTIVITY SEATS, OR UNISTRUT TRACK SEATING WITH 2 PASSENGER SEATS. THE SEATS MAY NOT HAVE HAD THE CORRECT HARDWARE INSTALLED ON THEM WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

Consequence Summary:
PASSENGERS COULD SUSTAIN SERIOUS INJURIES OR EVEN DEATH IN THE EVENT OF A VEHICLE CRASH.

Corrective Summary:
MID BUS WILL NOTIFY OWNERS AND PROVIDE ADDITIONAL HARDWARE ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT MID BUS AT 1-877-358-6055.

Recall Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V490000
Manufacturer: MID BUS CORPORATION
Manufactured Begin Date: January 1st, 2002
Manufactured End Date: April 30th, 2005
Date of Owner Notification: December 30th, 2005

Defect Summary:
CERTAIN MID BUS 2002-2005 MODEL YEAR GUIDE DX, GUIDE SW, GUIDE XL, AND SC SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 7, 2002, AND APRIL 30, 2005, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

Consequence Summary:
SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.

Corrective Summary:
MID BUS WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, MID BUS IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, MID BUS WILL REPLACE THE SWICH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, MID BUS WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE RECALL BEGAN ON DECEMBER 30, 2005. OWNERS MAY CONTACT MID BUS AT 877-358-6055.

Recall Notes:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT.HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY.

---

NHTSA Campaign Number: 05V203000
Manufacturer: MID BUS CORPORATION
Manufactured Begin Date: January 1st, 2002
Manufactured End Date: April 30th, 2005
Date of Owner Notification: May 24th, 2005

Defect Summary:
CERTAIN MID BUS MY 2002-2005 GUIDE SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 2002 AND APRIL 30, 2005. THESE BUSES WERE EQUIPPED WITH A BENCH-STYLE SINGLE PASSENGER SEATS HAVING A LOWER CUSHION SURFACE OF 24 INCHES IN WIDTH. THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES FOR A SIGNAL DESIGNATED SEATING POSITION. THESE SEATS DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

Consequence Summary:
THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES WIDE TO HAVE A SINGLE DESIGNATED SEATING POSITION. BECAUSE THE 24 INCH CUSHION IS WIDER THAN 22 INCHES, THE POTENTIAL EXISTS FOR TWO PASSENGERS TO BE SEATED IN THIS SEAT. A SECOND PASSENGER WOULD NOT HAVE AN AVAILABLE SEAT BELT FOR RESTRAINT AND MAY BE INJURED IN A CRASH.

Corrective Summary:
MID BUS WILL NOTIFY ITS CUSTOMERS AND REPLACE THE 24 INCH SEAT CUSHION WITH A 22 INCH SEAT CUSHION FREE OF CHARGE. THE RECALL BEGAN ON MAY 24, 2005. OWNERS MAY CONTACT MID BUS AT 1-877-3358-6055.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 04V503000
Manufacturer: MID BUS CORPORATION

Defect Summary:
CERTAIN 2000-2004 MY MID BUS SCHOOL BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13 FOR USE ON CERTAIN SCHOOL AND TRANSIT BUSES. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.

Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO THE SEAT OCCUPANT AND/OR OTHER PASSENGERS.

Corrective Summary:
ONCE THE BUS OWNERS HAVE BEEN IDENTIFIED, SURE-LOK WILL NOTIFY MID BUS' CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR BUSES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK CUSTOMER SERVICE AT 866-787-3565.

Recall Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).