1994 Mercury Sable Recalls

---

NHTSA Campaign Number: 98V323000
Manufacturer: FORD MOTOR COMPANY
Manufacturer Campaign Number: 98S36
Manufactured Begin Date: October 14th, 1985
Manufactured End Date: June 27th, 1995
Date of Owner Notification: January 18th, 1999

Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence Summary:
IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Corrective Summary:
DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.

Recall Notes:
NOTE:THIS RECALL CAMPAIGN SUPERCEDES RECALL CAMPAIGN 93V-106.OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 18, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 98V009000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: December 1st, 1992
Manufactured End Date: September 30th, 1993
Date of Owner Notification: April 15th, 1998

Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.

Consequence Summary:
LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Corrective Summary:
DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.

Recall Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 15, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 97V025000
Manufacturer: FORD MOTOR COMPANY
Manufacturer Campaign Number: 97S65
Manufactured Begin Date: July 30th, 1990
Manufactured End Date: November 18th, 1994
Date of Owner Notification: April 23rd, 1997

Defect Summary:
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.

Consequence Summary:
DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.

Corrective Summary:
DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.

Recall Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 7, 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTRACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 97V019000
Manufacturer: FORD MOTOR COMPANY
Manufacturer Campaign Number: 97S66
Manufactured Begin Date: July 22nd, 1991
Manufactured End Date: November 18th, 1994
Date of Owner Notification: March 31st, 1997

Defect Summary:
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.

Consequence Summary:
THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.

Corrective Summary:
DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.

Recall Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 15, 1997.NOTES:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 94E036000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: January 1st, 1994
Manufactured End Date: November 1st, 1994
Date of Owner Notification: December 15th, 1994

Defect Summary:
THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.

Consequence Summary:
OVER TIME, A PORTION OF THE BRACKET CAN TEAR AWAY FROM THE STRUT, FALLING INTO AND PUNCTURING THE TIRE OR CAUSING DAMAGE TO THE WHEEL, WHICH COULD RESULT IN AN ACCIDENT.

Corrective Summary:
MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.

Recall Notes:
EQUIPMENT DESCRIPTION: AFTERMARKET SHOCK ABSORBERS FOR 1986 - 1994 FORD TAURUS AND MERCURY SABLE PASSENGER CARS; PART 71780, 81780.IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT MONROE AT 1-800-521-6754. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.