1977 Mercury Bobcat Recalls

---

NHTSA Campaign Number: 07E064000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: October 15th, 2007

Defect Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

Consequence Summary:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 83V025000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: August 1st, 1976
Manufactured End Date: July 1st, 1978
Date of Owner Notification: March 22nd, 1983

Defect Summary:
THE FLEXIBLE BLADE ENGINE COOLING FAN BLADES MAY CRACK AND BREAK OFF. THIS MAY BE CAUSED BY HIGH BLADE STRESSES THAT CAN RESULT FROM VIBRATION DURING VEHICLE OPERATION.

Corrective Summary:
DEALER WILL REPLACE THE DEFECTIVE ENGINE COOLING FAN AT NO COST TO OWNER.

Recall Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.8 LITER ENGINES ANDOPTIONAL AIR CONDITIONING.SYSTEM: ENGINE; ENGINE COOLING FAN.CONSEQUENCES OF DEFECT: A BLADE FRAGMENT MAY SEPARATE FROM THE FAN ASSEMBLYWITHOUT PRIOR WARNING. A BROKEN BLADE OR FRAGMENT MAY DAMAGE UNDER-HOODCOMPONENTS.NOTE: IF THE HOOD IS OPEN WHEN BLADE SEPARATION OCCURS, PERSONS NEAR THEVEHICLE COULD BE SERIOUSLY INJURED.

---

NHTSA Campaign Number: 76V140000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: September 20th, 1976

Recall Notes:
FORD CAMPAIGN NO 203.VEHICLES EQUIPPED WITH 2.3 LITRE ENGINES AND HOLLEYMODEL 5200 CARBURETORS.POSSIBILITY A POWER VALVE RESTRICTOR CROSS DRILLINGPLUG INSTALLED AT BASE OF THE CARBURETOR FUEL BOWL MAY LOOSEN OR DISLODGEBECAUSE OF INADEQUATE STAKING.A LOOSE OR MISSING PLUG WOULD PERMIT SPILLAGEOF GASOLINE AND CAUSE AN ACCUMULATION OF UNDERHOOD FUEL VAPORS AND THEPOTENTIAL FOR UNDERHOOD FIRE.(CORRECT BY INSPECTING AND APPLYING EPOXY SEALEROVER PLUG AND SURROUNDINGS AREA OF THE FUEL BOWL).PASSENGER VEHICLE.