1976 Mercury Bobcat Recalls

---

NHTSA Campaign Number: 07E064000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: October 15th, 2007

Defect Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

Consequence Summary:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 76V170000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: November 15th, 1976

Recall Notes:
FORD MOTOR CAMPAIGN NO 209.POSSIBILITY THAT VEHICLES EQUIPPED WITH 2.3LITRE ENGINES MAY EXPERIENCE FUEL LEAKAGE AT THE RUBBER HOSE CONNECTING THEFUEL TUBE TO THE CARBURETOR FUEL FILTER.FUEL LEAKAGE MAY BE CAUSED BY ACOMBINATION OF FACTORS, INCLUDING FUEL TUBE MISALIGNMENT, IMPROPER HOSECLAMPING AND A CHANGE TO A LESS FLEXIBLE, DOUBLE BRAIDED HOSE.FUEL ODORS MAYPROVIDE WARNING TO DRIVERS.SHOULD LEAKAGE OCCUR, A POTENTIAL EXISTS FOR THEOCCURANCE OF AN UNDERHOOD FIRE.(CORRECT BY INSPECTING AND REPLACING FUELHOSE, CLAMP AND ALIGNMENT OF FUEL TUBE WHEN NECESSARY).PASSENGER VEHICLE.

---

NHTSA Campaign Number: 78V069000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: June 9th, 1978

Defect Summary:
IN THE EVENT OF A FRONTAL IMPACT, FUEL LEAKAGE MAY OCCUR AT THE FUEL LINE TO FUEL PUMP CONNECTION IN THE ENGINE COMPARTMENT. THESE VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY".

Corrective Summary:
DEALER WILL INSTALL A PAIR OF FRONT BUMPER BRACKET EXTENSION PLATES TO SUPPLY ADDED PROTECTION FOR THIS FUEL LINE CONNECTION.

Recall Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL LINE TO FUEL PUMP CONNECTION.CONSEQUENCES OF DEFECT: FUEL LEAKAGE RESULTING FROM A VEHICLE COLLISION COULDLEAD TO A VEHICLE FIRE AND INJURY TO PASSENGERS.

---

NHTSA Campaign Number: 76V112000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: August 12th, 1976

Recall Notes:
FORD MOTOR CAMPAIGN NO 199.POSSIBILITY THAT THE FRONT SEAT BACK RESTRAININGDEVICES THAT MAY FAIL TO MEET THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETYSTANDARD NO.207.THIS CONDITION RESULTED BECAUSE SCREWS SECURING THE LATCHSTRIKER TO THE SEAT CUSHION FRAME WERE NOT PROPERLY PROCESSED BY THEIRMANUFATURER.(CORRECT BY INSPECTING AND REPLACING SCREW AS NECESSARY).PASSENGER VEHICLE.

---

NHTSA Campaign Number: 78V143000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: August 1st, 1971
Manufactured End Date: July 1st, 1976
Date of Owner Notification: August 22nd, 1978

Defect Summary:
IN THE EVENT THE VEHICLE IS STRUCK FROM THE REAR, THE FUEL FILLER PIPE COULD DISCONNECT FROM THE TANK OR THE TANK COULD BE PUNCTURED IN THE FORWARD FACE. THIS WOULD RESULT IN FUEL LEAKAGE.

Corrective Summary:
THE DEALER WILL INSTALL A LONGER FUEL FILLER PIPE HAVING AN IMPROVED SEAL. ALSO, A POLYETHYLENE SHIELD WILL BE INSTALLED ON THE FRONT OF THE FUEL TANK.

Recall Notes:
VEHICLE DESCRIPTON: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL TANK.CONSEQUENCES OF DEFECT: FUEL LEAKAGE, IN THE PRESENCE OF A SOURCE OF IGNITION,COULD RESULT IN A VEHICLE FIRE AND SERIOUS INJURY TO PASSENGERS.

---

NHTSA Campaign Number: 76V067000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: May 18th, 1976

Recall Notes:
FORD CAMPAIGN NO 192. POSSIBILITY THAT THE NYLON BUSHING IN THE ACCELERATORNCABLE MAY BECOME LOOSE DUE TO AN OVERSIZE RETAINING CLIP. A LOOSE BUSHING MAYLRESTRICT THE ACCELERATOR CABLE FROM RETURNING TO IDLE OR TO A LOWER SPEEDOR TO A SLOWER SPEED CONDITION, HOLDING CARBURETOR AT CONSTANT SPEED. SHOULDTHIS OCCUR, THE DRIVER CAN STOP THE VEHICLE BY APPLYING THE BRAKES, SHIFTINGTO NEUTRAL AND TURNING OFF THE IGNITION. (CORRECT BY INSPECTING THE BUSHINGBUSHING RETAINING CLIP WHERE NECESSARY.)