2002 Jayco Legacy Recalls

---

NHTSA Campaign Number: 09V288000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: August 15th, 2001
Manufactured End Date: April 28th, 2004
Date of Owner Notification: July 31st, 2009

Defect Summary:
JAYCO IS RECALLING 273 MODEL YEAR 2002-2004 LEGACY FIFTH WHEEL MOTORHOMES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Consequence Summary:
IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Corrective Summary:
JAYCO WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 04V364000
Manufacturer: JAYCO, INC.
Manufacturer Campaign Number: 9901054
Manufactured Begin Date: May 30th, 2001
Manufactured End Date: December 7th, 2002
Date of Owner Notification: October 18th, 2004

Defect Summary:
ON CERTAIN TRAVEL TRAILERS, DUE TO VARIOUS FACTORS, INCLUDING EXCESSIVE PAINT COATING ON THE BRAKE HUB, THE ALUMINUM WHEELS COULD EXHIBIT LESSENED CLAMPING PRESSURE BETWEEN THE ALUMINUM WHEEL AND THE AXLE HUB ASSEMBLY.

Consequence Summary:
THIS COULD LEAD TO WHEEL SEPARATION, WHICH COULD RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL INSPECT ALL WHEELS, LUGS, STUDS AND MATING SURFACES, AND REMOVE PAINT FROM THE MATING SURFACES OF THE WHEEL AND HUB. THE RECALL BEGAN ON OCTOBER 18, 2004. OWNERS SHOULD CONTACT JAYCO AT 1-219-825-5861.

Recall Notes:
JAYCO RECALL NO. 9901054.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V383000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: July 6th, 2001
Manufactured End Date: October 15th, 2003

Defect Summary:
ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence Summary:
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Corrective Summary:
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR JAYCO AT 1-574-825-0608.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).