2005 Jayco Granite Ridge Recalls

---

NHTSA Campaign Number: 06V109000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: March 1st, 2005
Manufactured End Date: April 30th, 2005

Defect Summary:
CERTAIN MOTOR HOMES BUILT ON FORD E-450 CHASSIS, AND EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.

Consequence Summary:
AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.

Corrective Summary:
OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267 .

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 06V095000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: November 1st, 2002
Manufactured End Date: June 30th, 2004

Defect Summary:
CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Consequence Summary:
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Corrective Summary:
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 06V082000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: November 1st, 2002
Manufactured End Date: June 30th, 2004

Defect Summary:
ON CERTAIN MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION, COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Consequence Summary:
THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Corrective Summary:
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V556000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: July 11th, 2003
Manufactured End Date: August 5th, 2004
Date of Owner Notification: January 10th, 2006

Defect Summary:
ON CERTAIN MOTOR HOMES, THE HITCH RECEIVER MAY HAVE MISSING REINFORCING PLATES. WHEN A LOAD IS APPLIED TO THE HITCH, IT MAY BECOME PARTIALLY DETACHED FROM THE FRAME IF THESE PLATES ARE MISSING.

Consequence Summary:
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, PERSONAL INJURY OR DEATH.

Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE REINFORCING PLATES WITH NEW HARDWARE. THE RECALL BEGAN ON JANUARY 10, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V008000
Manufacturer: JAYCO, INC.
Manufactured Begin Date: July 13th, 2004
Manufactured End Date: December 2nd, 2004
Date of Owner Notification: February 28th, 2005

Defect Summary:
ON CERTAIN MOTOR HOMES THE BATTERY CABLE MAY HAVE BEEN ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD.

Consequence Summary:
THIS COULD CAUSE THE CABLE TO MELT, CREATING AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.

Corrective Summary:
DEALERS WILL INSPECT AND REROUTE AND/OR REPLACE THE BATTERY CABLE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 28, 2005. OWNERS MAY CONTACT JAYCO AT 574-825-5861.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.