2004 Jaguar Xj Recalls

---

NHTSA Campaign Number: 09V144000
Manufacturer: JAGUAR CARS LTD
Manufacturer Campaign Number: J012
Manufactured Begin Date: January 2nd, 2003
Manufactured End Date: January 19th, 2004
Date of Owner Notification: June 1st, 2009

Defect Summary:
JAGUAR IS RECALLING 14,551 MY 2004 XJ VEHICLES. A POTENTIAL CONCERN HAS BEEN IDENTIFIED WITH THE INSTALLATION OF A NOISE VIBRATION AND HARSHNESS (NVH) PAD FITTED TO THE UNDER TRAY AND ITS INTERACTION WITH THE REAR UNDER FLOOR BRAKE PIPES, REAR CROSS MEMBER BRAKE PIPES, AND THEIR UNIONS. A REVIEW OF VEHICLE BUILD CONDITIONS PROVIDES EVIDENCE THAT A TOUCH CONDITION CAN EXIST BETWEEN THE UNDER FLOOR AND CROSS MEMBER BRAKE PIPES AND THE NVH PAD AT THE REAR OF THE UNDER FLOOR UNDER TRAY. WHERE THE TOUCH CONDITION EXISTS, WATER AND DIRT CAN COLLECT AND BE HELD IN CONTACT WITH THE PIPES AND THEIR UNIONS, ABRADE THE CORROSION PROTECTION AND REDUCE THE CORROSION LIFE OF THE PIPES ACCORDINGLY.

Consequence Summary:
CORROSION OF THE BRAKE PIPES CAN LEAD TO A LOSS OF MECHANICAL INTEGRITY OF THE BRAKING SYSTEM. THIS CAN RESULT IN EXTENDED BRAKE PEDAL TRAVEL COMBINED WITH REDUCED BRAKING PERFORMANCE IN THE CORRESPONDING BRAKE CIRCUIT. THE INSTRUMENT CLUSTER MAY DISPLAY THE WARNING MESSAGE 'FLUID LEVEL LOW', ALONG WITH THE BRAKE WARNING LAMP BEING ILLUMINATED. IN THE EVENT OF BOTH BRAKING CIRCUITS LOSING INTEGRITY AT THE SAME TIME, COMPLETE LOSS OF SERVICE BRAKES WILL OCCUR, THEREBY POTENTIALLY CAUSING A VEHICLE CRASH.

Corrective Summary:
DEALERS WILL REMOVE THE UNDER TRAY AT THE REAR OF THE VEHICLE AND REMOVE AND DISCARD THE NVH PAD FITTED TO THE REAR OF THE UNDER TRAY. DEALERS WILL INSPECT THE REAR UNDER FLOOR AND REAR CROSS MEMBER BRAKE PIPES AND UNIONS FOR RED RUST. IF RED RUST IS PRESENT ON THE PIPES OR ON THE UNION, THE BRAKE PIPES AND UNION WILL BE REPLACED WITH NEW COMPONENTS OF THE SAME DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT JAGUAR AT 1-800-452-4827.

Recall Notes:
JAGUAR RECALL NO. J012.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 04V136000
Manufacturer: JAGUAR CARS LTD
Manufacturer Campaign Number: R719
Manufactured Begin Date: November 1st, 2003
Manufactured End Date: January 31st, 2004
Date of Owner Notification: May 14th, 2004

Defect Summary:
ON CERTAIN PASSENGER VEHICLES, THE PASSENGER AIR BAG TRIM COMPONENTS HAVE A POOR APERTURE EDGE.

Consequence Summary:
SHOULD THE AIR BAG DEPLOY, IT COULD BE CUT, CAUSING IT TO NOT INFLATE PROPERLY, WHICH INCREASES THE RISK OF INJURY TO THE OCCUPANT IN A CRASH.

Corrective Summary:
DEALERS WILL INSPECT THE PASSENGER AIR BAG APERTURE AND, WHERE NECESSARY, REMOVE ANY SHARP, SERRATED EDGES. THE RECALL BEGAN ON MAY 14, 2004. OWNERS SHOULD CONTACT JAGUAR AT 1-800-452-4827.

Recall Notes:
JAGUAR RECALL NO. R719.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 04V024000
Manufacturer: JAGUAR CARS LTD
Manufacturer Campaign Number: R513
Manufactured Begin Date: December 1st, 2002
Manufactured End Date: June 30th, 2003
Date of Owner Notification: May 1st, 2004

Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS, WITH THE FORWARD DRIVE GEAR SELECTED AND THE VEHICLE STATIONARY OR IN A FORWARD MOTION, THE GEARBOX COULD POTENTIALLY SELECT REVERSE GEAR, WITHOUT INDICATION.

Consequence Summary:
THIS FAILURE COULD RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL REPROGRAM THE TRANSMISSION CONTROL MODULE. THE RECALL BEGAN ON MAY 1, 2004. OWNERS SHOULD CONTACT JAGUAR AT 1-201-818-8500.

Recall Notes:
JAGUAR RECALL NO. R513.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).