2006 International 8600 Recalls

---

NHTSA Campaign Number: 07V314000
Manufacturer: Navistar, Inc.
Manufacturer Campaign Number: 7511
Manufactured Begin Date: November 1st, 2005
Manufactured End Date: April 30th, 2007
Date of Owner Notification: September 28th, 2007

Defect Summary:
ON CERTAIN 6X4 OR 6X6 TRUCKS WITH AIR BRAKES OR TRACTORS WITH AIR BRAKES AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Consequence Summary:
THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.

Corrective Summary:
INTERNATIONAL IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 2007. OWNERS MAY CONTACT BENDIX AT 440-329-9000 AND INTERNATIONAL AT 1-800-448-7825.

Recall Notes:
INTERNATIONAL RECALL NO. 07511.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V567000
Manufacturer: Navistar, Inc.
Manufacturer Campaign Number: 5523
Date of Owner Notification: December 21st, 2005

Defect Summary:
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE ENGINE ELECTRICAL GROUND CABLE THAT CONNECTS THE ENGINE BLOCK WITH THE STARTER MAY BE ROUTED IN A WAY THAT COULD CAUSE CHAFING AGAINST THE STARTER'S POSITIVE BATTERY CABLES.

Consequence Summary:
IF CHAFING OCCURS BETWEEN THE POSITIVE AND NEGATIVE CABLES, AN ELECTRICAL SHORT MAY RESULT AND MAY CAUSE A VEHICLE FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.

Corrective Summary:
DEALERS WILL INSPECT THE ENGINE GROUND CABLES FOR PROPER ROUTING. IF ANY CHAFING IS FOUND, THE ENGINE BLOCK GROUND CABLE WILL BE REPLACED WITH A SHORTER (280MM) CABLE AND ANY OTHER DAMAGED CABLES WILL BE REPLACED AND ROUTED CORRECTLY FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Recall Notes:
INTERNATIONAL RECALL NO.05523.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V188000
Manufacturer: Navistar, Inc.
Manufacturer Campaign Number: 5511
Manufactured Begin Date: October 10th, 2001
Manufactured End Date: March 21st, 2005
Date of Owner Notification: August 5th, 2005

Defect Summary:
ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.

Consequence Summary:
IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.

Corrective Summary:
DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.

Recall Notes:
INTERNATIONAL RECALL NO.05511. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.