2008 Ic Bus Ce Recalls

---

NHTSA Campaign Number: 15V870000
Manufacturer: IC CORPORATION
Manufactured Begin Date: January 23rd, 2006
Manufactured End Date: May 12th, 2014
Date of Owner Notification: February 19th, 2016

Defect Summary:
Navistar, Inc. is recalling certain model year 2007-2015 IC CE transit buses, 2008-2011 IC FE transit buses and 2009-2013 IC RE transit buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence Summary:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Corrective Summary:
Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 15V868000
Manufacturer: IC CORPORATION
Manufactured Begin Date: January 2nd, 2006
Manufactured End Date: September 23rd, 2014
Date of Owner Notification: February 19th, 2016

Defect Summary:
Navistar, Inc. is recalling certain model year 2007-2015 IC BE and CE school buses, 2013-2015 IC AE school buses, 2007-2011 IC FE school buses, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence Summary:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Corrective Summary:
Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 14V692000
Manufacturer: Navistar, Inc.
Manufacturer Campaign Number: 14518
Manufactured Begin Date: January 2nd, 2006
Manufactured End Date: September 23rd, 2014
Date of Owner Notification: January 29th, 2015

Defect Summary:
Navistar, Inc. (Navistar) is recalling certain model year 2013-2015 IC AE, 2007-2015 IC BE, CE, 2007-2011 IC FE, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence Summary:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Corrective Summary:
Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14518.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 14V691000
Manufacturer: Navistar, Inc.
Manufacturer Campaign Number: 14517
Manufactured Begin Date: January 23rd, 2006
Manufactured End Date: May 12th, 2014
Date of Owner Notification: January 29th, 2015

Defect Summary:
Navistar, Inc.(Navistar) is recalling certain model year 2007-2015 IC CE transit buses manufactured January 23,2006, to May 12, 2014, 2008, and 2011 IC FE transit buses manufactured October 5, 2006, to September 28, 2009, and 2009-2010, and 2013 IC RE transit buses manufactured September 19, 2007, to November 29, 2011, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence Summary:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Corrective Summary:
Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The interim notices were mailed on December 29, 2014. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14517.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 11V428000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 11519
Manufactured Begin Date: June 27th, 2006
Manufactured End Date: March 23rd, 2011
Date of Owner Notification: September 27th, 2011

Defect Summary:
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2007-2012 IC CE AND BE COMMERCIAL BUSES MANUFACTURED FROM JUNE 27, 2006, THROUGH MARCH 23, 2011, EQUIPPED WITH A MAXXFORCE 7 ENGINE FEATURE CODE 12NTH, 12NTD, 12NTE, 12NTG, 12VYY, OR 12627 AND ALTERNATOR FEATURE CODE 0008GGR, 0008GGM, 0008GWX, OR 0008GEL. THE POSITIVE ALTERNATOR CABLE MAY RUB ON THE ENGINE CONTROL MODULE MOUNTING BRACKET, POSSIBLY CHAFING ITS INSULATION AND CAUSING AN ELECTRICAL SHORT.

Consequence Summary:
AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE ALTERNATOR CABLE. TIE STRAPS WILL BE INSTALLED TO ROUTE THE ALTERNATOR CABLE AWAY FROM THE ENGINE CONTROL MODULE MOUNTING BRACKET. THESE REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 27, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S CAMPAIGN NUMBER IS 11518.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 11V427000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 11518
Manufactured Begin Date: June 27th, 2006
Manufactured End Date: March 23rd, 2011
Date of Owner Notification: September 27th, 2011

Defect Summary:
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2007-2012 IC CE AND BE SCHOOL BUSES MANUFACTURED FROM JUNE 27, 2006, THROUGH MARCH 23, 2011, EQUIPPED WITH A MAXXFORCE 7 ENGINE FEATURE CODE 12NTH, 12NTD, 12NTE, 12NTG, 12VYY, OR 12627 AND ALTERNATOR FEATURE CODE 0008GGR, 0008GGM, 0008GWX, OR 0008GEL. THE POSITIVE ALTERNATOR CABLE MAY RUB ON THE ENGINE CONTROL MODULE MOUNTING BRACKET, POSSIBLY CHAFING ITS INSULATION AND CAUSING AN ELECTRICAL SHORT.

Consequence Summary:
AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE ALTERNATOR CABLE AND THE INSTALLATION OF THE TIE STRAPS TO ROUTE THE ALTERNATOR CABLE AWAY FROM THE ENGINE CONTROL MODULE MOUNTING BRACKET. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 27, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S RECALL CAMPAIGN NUMBER IS 11518.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 11V375000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 11514
Manufactured Begin Date: November 1st, 2006
Manufactured End Date: May 2nd, 2011
Date of Owner Notification: August 3rd, 2011

Defect Summary:
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2012 IC BE, CE, AND FE SCHOOL BUSES MANUFACTURED FROM NOVEMBER 1, 2006, THROUGH MAY 2, 2011. THE REFLECTIVE TAPE FOR THE REAR EXIT DOOR MAY NOT HAVE BEEN TOTALLY COMPLETED. ACCORDINGLY, THE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence Summary:
THIS NONCOMPLIANCE MAY REDUCE CONSPICUITY OF THE REAR DOOR, REDUCING THE ABILITY OF EMERGENCY PERSONNEL TO IDENTIFY AND GAIN ACCESS TO THE REAR EXIT DURING AN EMERGENCY, POSSIBLY INCREASING THE OCCUPANT'S RISK OF PERSONAL INJURY OR DEATH DURING AN EMERGENCY.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE BUSES AND ADD REFLECTIVE TAPE IF NECESSARY. THE SAFETY RECALL BEGAN ON AUGUST 3, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S RECALL CAMPAIGN NUMBER IS 11514.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V267000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 10512
Manufactured Begin Date: December 4th, 2001
Manufactured End Date: December 14th, 2009
Date of Owner Notification: July 1st, 2010

Defect Summary:
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 INTERNATIONAL TRUCKS AND IC COMMERCIAL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.

Consequence Summary:
THIS INCREASE TO HIGH IDLE SPEED MAY OCCUR WITHOUT WARNING CAUSING A SUDDEN AND UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S CAMPAIGN NUMBER IS 10512.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V265000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 10512
Manufactured Begin Date: December 4th, 2001
Manufactured End Date: December 14th, 2009
Date of Owner Notification: July 1st, 2010

Defect Summary:
NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 IC BE, RE, AND CE SCHOOL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.

Consequence Summary:
THIS INCREASE TO HIGH IDLE SPEED MAY OCCUR WITHOUT WARNING CAUSING A SUDDEN AND UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825..

Recall Notes:
NAVISTAR'S RECALL CAMPAIGN NUMBER IS 10512.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V103000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 10505
Manufactured Begin Date: November 19th, 2003
Manufactured End Date: February 9th, 2010
Date of Owner Notification: April 2nd, 2010

Defect Summary:
NAVISTAR HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 AND 2011 IC CE, BE, AND FE SCHOOL BUSES MANUFACTURED FROM NOVEMBER 19, 2003 THROUGH FEBRUARY 9, 2010. THE PARKING BRAKE MAY RELEASE IF THE BRAKE SYSTEM ELECTRONIC CONTROL UNIT SOFTWARE MISINTERPRETS INPUT SIGNALS GENERATED FROM CYCLING THE IGNITION SWITCH MORE THAN ONCE AT A SPECIFIC FREQUENCY.

Consequence Summary:
RELEASE OF THE PARKING BRAKE MAY CAUSE SUDDEN, UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL DAMAGE, OR DEATH.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND WILL REPAIR THE BUSES BY REPROGRAMMING THE VEHICLE'S BRAKE SYSTEM ECU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 2, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890.

Recall Notes:
NAVISTAR'S RECALL CAMPAIGN NUMBER IS 10505.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V052000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 9501
Manufactured Begin Date: February 2nd, 2000
Manufactured End Date: June 2nd, 2008
Date of Owner Notification: July 2nd, 2009

Defect Summary:
NAVISTAR IS RECALLING 61,316 MY 2001 THROUGH 2009 IC BE, CE, AND FE MODEL COMMERCIAL AND SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 2, 2000 AND JUNE 2, 2008, EQUIPPED WITH AN ENTRANCE DOOR STEPWELL HEATER FEATURE CODE 0048PMS OR 0548001 AND/OR A REAR WALL MOUNTED HEATER FEATURE CODE 0048TAR OR 0048PSX. THE AFFECTED HEATER UNITS MAY FAIL IN LOW SPEED OPERATION CAUSING ELEVATED TEMPERATURES.

Consequence Summary:
ELEVATED TEMPERATURES CAN RESULT IN A FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Corrective Summary:
AN INTERIM LETTER WAS MAILED ON FEBRUARY 20, 2009, TO COMMUNICATE THE DEFECT AND RECOMMEND ACTION TO MITIGATE THE RISK UNTIL THE FINAL REMEDY AND CUSTOMER NOTIFICATION COULD BE PROVIDED AT A LATER DATE. THE MANUFACTURE FILED AN AMENDED DEFECT REPORT DATED MARCH 27, 2009 ADVISING THAT A FINAL REMEDY HAS BEEN DEVELOPED AND PARTS ARE BEING MANUFACTURED. THE SAFETY RECALL BEGAN ON JUNE 2, 2009. OWNERS MAY CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S RECALL NO. 09501.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V052000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 9501
Manufactured Begin Date: February 2nd, 2000
Manufactured End Date: June 2nd, 2008
Date of Owner Notification: July 2nd, 2009

Defect Summary:
NAVISTAR IS RECALLING 61,316 MY 2001 THROUGH 2009 IC BE, CE, AND FE MODEL COMMERCIAL AND SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 2, 2000 AND JUNE 2, 2008, EQUIPPED WITH AN ENTRANCE DOOR STEPWELL HEATER FEATURE CODE 0048PMS OR 0548001 AND/OR A REAR WALL MOUNTED HEATER FEATURE CODE 0048TAR OR 0048PSX. THE AFFECTED HEATER UNITS MAY FAIL IN LOW SPEED OPERATION CAUSING ELEVATED TEMPERATURES.

Consequence Summary:
ELEVATED TEMPERATURES CAN RESULT IN A FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Corrective Summary:
AN INTERIM LETTER WAS MAILED ON FEBRUARY 20, 2009, TO COMMUNICATE THE DEFECT AND RECOMMEND ACTION TO MITIGATE THE RISK UNTIL THE FINAL REMEDY AND CUSTOMER NOTIFICATION COULD BE PROVIDED AT A LATER DATE. THE MANUFACTURE FILED AN AMENDED DEFECT REPORT DATED MARCH 27, 2009 ADVISING THAT A FINAL REMEDY HAS BEEN DEVELOPED AND PARTS ARE BEING MANUFACTURED. THE SAFETY RECALL BEGAN ON JUNE 2, 2009. OWNERS MAY CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S RECALL NO. 09501.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 08V353000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 8506
Manufactured Begin Date: September 21st, 2001
Manufactured End Date: December 14th, 2007
Date of Owner Notification: October 3rd, 2008

Defect Summary:
NAVISTAR IS RECALLING 24,975 MY 2003 THROUGH 2008 IC BE, CE, HC, AND RE SCHOOL AND COMMERCIAL BUSES AND 2002 THROUGH 2008 INTERNATIONAL 3200 AND 3300 MODEL BUSES MANUFACTURED BETWEEN SEPTEMBER 21, 2001 THROUGH DECEMBER 14, 2007, EQUIPPED WITH INTERNATIONAL VT365 ENGINES. THESE VEHICLES MAY EXHIBIT ENGINE HARD START, NO START, OR STALL CONDITIONS DUE TO POSSIBLY DAMAGED TERMINALS IN THE FUSE HOLDER CONNECTOR OF THE INJECTOR DRIVE MODULE (IDM) CLEAN BATTERY POWER CIRCUITS. THE TERMINALS MAY HAVE BEEN DAMAGED DURING ELECTRICAL CONTINUITY TESTING IN THE MANUFACTURING PROCESS.

Consequence Summary:
THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND REPLACE THE IDM FUSE HOLDER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 3, 2008. OWNERS CAN CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.

Recall Notes:
NAVISTAR'S RECALL NO. 08506.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 08V258000
Manufacturer: IC CORPORATION
Manufacturer Campaign Number: 8505
Manufactured Begin Date: November 21st, 2000
Manufactured End Date: May 21st, 2008
Date of Owner Notification: July 10th, 2008

Defect Summary:
NAVISTAR IS RECALLING 51,588 HEAVY TRUCKS, COMMERCIAL BUSES AND SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 21, 2000 AND MAY 21, 2008, EQUIPPED WITH ONE OR MORE REMOTE POWER MODULES. THE POTTING MATERIAL THAT ENCAPSULATES THE CIRCUIT BOARD OF THE VEHICLE'S REMOTE POWER MODULE MAY NOT SUFFICIENTLY SEAL THE CIRCUIT BOARD FROM WATER AND CONTAMINATION INTRUSION. IF THE ENCAPSULATION IS COMPROMISED, WATER AND CONTAMINANTS MAY CAUSE AN INTERNAL ELECTRICAL SHORT, POSSIBLY RESULTING IN A FIRE.

Consequence Summary:
A FIRE COULD CAUSE PERSONAL INJURY OR DEATH.

Corrective Summary:
NAVISTAR WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2008. OWNERS MAY CONTACT NAVISTAR AT 1-280-461-1890.

Recall Notes:
NAVISTAR RECALL NO. 08505.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.