2010 Girardin Mb Ii Recalls

---

NHTSA Campaign Number: 11V228000
Manufacturer: GIRARDIN MINIBUS INC.
Manufacturer Campaign Number: 11-042-8WU
Date of Owner Notification: June 2nd, 2011

Defect Summary:
CERTAIN MODEL YEAR 2006 THROUGH 2010 GIRARDIN G5 AND MBII AND MODEL YEAR 2010 AND 2011 MICRO BIRD G5 AND MB II SCHOOL BUSES MANUFACTURED FROM JANUARY 2006 THROUGH APRIL 5, 2011, FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 131, "SCHOOL BUS PEDESTRIAN SAFETY DEVICES." THE 4-WAY WARNING LIGHTS DO NOT HAVE AN ALARM TO ALERT THE DRIVER THAT THE STOP ARM DID NOT DEPLOY WHEN THE 4 RED LIGHTS ARE ACTIVATED.

Consequence Summary:
THE DRIVER COULD ERRONEOUSLY THINK THAT THE SCHOOL BUS STOP ARM IS DEPLOYED WHILE THE FIRST SET OF 4 RED LIGHTS ARE ACTIVATED. THIS CONDITION INCREASES RISK OF INJURY TO PEDESTRIANS.

Corrective Summary:
MICRO BIRD WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE AFFECTED WARNING LIGHTS WITH WARNING LIGHTS THAT HAVE AN ALARM FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JUNE 2011. OWNERS MAY CONTACT MICRO BIRD AT 1-819-477-2012.

Recall Notes:
MICRO BIRD'S RECALL CAMPAIGN NUMBER IS 10-042-8WU.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V123000
Manufacturer: GIRARDIN MINIBUS INC.
Manufacturer Campaign Number: 10-037-RIU
Manufactured Begin Date: October 1st, 2007
Manufactured End Date: March 22nd, 2010
Date of Owner Notification: April 1st, 2010

Defect Summary:
CORP. MICRO BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2009 AND 2010 SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 2008 AND MARCH 2010 FITTED WITH RICON PUBLIC USE S AND K SERIES WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFTS UP FUNCTION, IF THE SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Consequence Summary:
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

Corrective Summary:
CORP. MICRO BIRD WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. CURRENTLY RICON IS DEVELOPING A SOFTWARE SOLUTION AND IS NOT AVAILABLE. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MICRO BIRD AT 1-819-477-2012.

Recall Notes:
MICRO BIRD'S CAMPAIGN NUMBER IS 10-037-RIU.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V121000
Manufacturer: GIRARDIN MINIBUS INC.
Manufacturer Campaign Number: 10-036-RIU
Manufactured Begin Date: December 1st, 2007
Manufactured End Date: March 23rd, 2010
Date of Owner Notification: March 31st, 2010

Defect Summary:
CORP. MICRO BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2007 THROUGH 2010 SCHOOL BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND MARCH 2010 FITTED WITH RICON PUBLIC USE S AND K SERIES WHEELCHAIR LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Corrective Summary:
MICRO BIRD IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON M,ARCH 31, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MICRO BIRD AT 1-819-477-2012.

Recall Notes:
MICRO BIRD'S CAMPAIGN NUMBER IS 10-036-RIU.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .