1993 Freightliner Fl-60 Recalls

---

NHTSA Campaign Number: 95E003005
Manufacturer: FREIGHTLINER LLC
Manufactured Begin Date: November 1st, 1992
Manufactured End Date: February 1st, 1995

Defect Summary:
AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVER PRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.

Consequence Summary:
IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGECAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.

Corrective Summary:
DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.

Recall Notes:
SYSTEM: BRAKES; AIR DRYER.VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH ROCKWELL WABCO SYSTEM SAVER "1000" OR SYSTEM SAVER "TWIN" AIR DRYERS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT FREIGHTLINER AT 1-503-735-8000.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V094000
Manufacturer: FREIGHTLINER LLC
Manufactured Begin Date: May 1st, 1991
Manufactured End Date: February 1st, 1995
Date of Owner Notification: September 14th, 1995

Defect Summary:
THE PARKING BRAKE LEVER MAY NOT TRAVEL FAR ENOUGH OVER CENTER TO ASSURE THAT IT REMAINS IN THE PROPER POSITION ALLOWING THE VEHICLE TO ROLL AWAY WHILE PARKED.

Consequence Summary:
IF THE VEHICLE IS NOT PROPERLY PARKED WITH THE TRANSMISSION IN THE CORRECT POSITION, AND IF THE VEHICLE IS PARKED ON A GRADE, IT COULD UNINTENTIONALLY ROLL AWAY INCREASING THE POTENTIAL FOR AN ACCIDENT.

Corrective Summary:
DEALERS WILL REMOVE AND REPLACE THE PARKING BRAKE LEVER WITH A LEVER THAT REQUIRES A 25 LB. EFFORT TO RELEASE.

Recall Notes:
SYSTEM: EMERGENCY PARKING BRAKE; MECHANICAL; LEVER.VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS EQUIPPED WITH MECHANICAL PARKING BRAKE.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT FREIGHTLINER AT 1-503-735-8000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V018000
Manufacturer: FREIGHTLINER LLC
Manufactured Begin Date: May 1st, 1991
Manufactured End Date: February 1st, 1995
Date of Owner Notification: April 28th, 1995

Defect Summary:
THE BRAKE CHAMBER MOUNTING STUDS CAN LOOSEN OR PULL THROUGH DUE TO FATIGUE IN THE BRAKE CHAMBER HOUSING CAUSED BY FOUNDATION BRAKE CHATTER.

Consequence Summary:
THIS CONDITION CAN RESULT IN LOSS OF BRAKING CAPABILITY.

Corrective Summary:
DEALERS WILL CHANGE THE BRAKE LINING MATERIALS, REPLACE THE WING BRACKET WITH A REINFORCED BRACKET AND INSTALL BRAKE CHAMBERS WITH REINFORCED CHAMBER HOUSING AND LARGER (1/2") MOUNTING STUDS.

Recall Notes:
SYSTEM: BRAKES; AIR;DRUM AND SHOE SYSTEM; CHAMBER.VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH 12" AND 16" FRONT BRAKE CHAMBERS MOUNTED ON ROCKWELL FOUNDATION BRAKES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT FREIGHTLINER AT 1-503-735-8000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.