1990 Ford Thunderbird Recalls

---

NHTSA Campaign Number: 09E012000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: May 11th, 2009

Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 96V071000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: August 1st, 1987
Manufactured End Date: September 30th, 1992
Date of Owner Notification: June 7th, 1996

Defect Summary:
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Consequence Summary:
THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.

Corrective Summary:
DEALERS WILL REPLACE THE IGNITION SWITCH.

Recall Notes:
SYSTEM: ELECTRICAL; IGNITION SWITCH. VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES AND LIGHT DUTY TRUCKS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 91V076000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: February 1st, 1990
Manufactured End Date: October 1st, 1990
Date of Owner Notification: May 24th, 1991

Defect Summary:
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.

Consequence Summary:
CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.

Corrective Summary:
APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.

Recall Notes:
SYSTEM: WINDSHIELD WIPER ASSEMBLY.VEHICLE DESCRIPTION: PASSENGER CARS.

---

NHTSA Campaign Number: 90V026000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: January 1st, 1990
Manufactured End Date: January 1st, 1990
Date of Owner Notification: March 9th, 1990

Defect Summary:
BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.

Consequence Summary:
CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.

Corrective Summary:
REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.

Recall Notes:
SYSTEM: BATTERY TO STARTER CABLE.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 3.8 LITER ENGINES.