1995 Ford F800 Recalls

---

NHTSA Campaign Number: 95E003008
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: February 1st, 1993
Manufactured End Date: March 1st, 1994

Defect Summary:
AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.

Consequence Summary:
IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.

Corrective Summary:
DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.

Recall Notes:
SYSTEM: BRAKES; AIR DRYER.VEHICLE DESCRIPTION: TRUCKS AND CHASSIS-CAB VEHICLES EQUIPPED WITH AIR BRAKES AND ROCKWELL WABCO SYSTEM SAVER "1000" AIR DRYER.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT ROCKWELL WABCO AT 1-800-535-5560 OR FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V143000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: March 1st, 1993
Manufactured End Date: August 1st, 1994
Date of Owner Notification: October 25th, 1995

Defect Summary:
THE HAND THROTTLE CABLE CAN WEAR THE BRASS SWIVEL BLOCK ON THE GOVERNOR LEVER THROUGH WHICH IT PASSES.

Consequence Summary:
THIS WEAR CAN RESULT IN THE GOVERNOR JAMMING IN THEDAMAGED SWIVEL AND COULD PREVENT THE GOVERNOR LEVER FROM RETURNING TO THE IDLE POSITION.

Corrective Summary:
DEALERS WILL INSTALL A REVISED GOVERNOR LEVER WITH A STAINLESS STEEL SWIVEL. ALSO LETTERS WILL BE SENT TO VEHICLE OWNERS THAT HAVE THE SAME VEHICLES BUT DO NOT HAVE A FORD INSTALLED HAND THROTTLE ADVISING THEM THAT THEY MAY REQUIRE SERVICE IF THEY HAVE HAD AN AFTER MARKET HAND THROTTLE INSTALLED.

Recall Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL.VEHICLE DESCRIPTION: TRUCKS, CHASSIS-CABS AND COWL-CHASSIS VEHICLES WITH INLINE FUEL INJECTION PUMP EQUIPPED FD-1060 OR FD-1460 ENGINES AND HAND THROTTLES.NOTE: THE VEHICLE BRAKES ARE CAPABLE OF OVERRIDING THE ENGINE POWER AND BRINGING THE VEHICLE TO A STOP.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLET IME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V092000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: August 1st, 1993
Manufactured End Date: August 1st, 1994
Date of Owner Notification: August 4th, 1995

Defect Summary:
A CONNECTOR IN THE WIRING WHERE THE TILT HOOD MOUNTED LAMPS ATTACH TO THE VEHICLE WIRING HARNESS WAS BUILT WITHOUT SEALING PLUGS. MOISTURE, ROAD SALT OR OTHER CONTAMINANTS CAN ENTER THE CONNECTION RESULTING IN CROSSED CIRCUITS, SHORTS OR CORROSION OF THE WIRING OF THE CONNECTOR.

Consequence Summary:
THE HEADLAMPS OR OTHER FRONT-END LIGHTING SYSTEMS CAN MALFUNCTION AS A RESULT OF THIS CONDITION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Corrective Summary:
DEALERS WILL INSPECT THE CONNECTOR AND INSTALL SEALING PLUGS IN THE OPEN CAVITIES. IF THE INSPECTION REVEALS CORROSION, A NEW CONNECTOR WILL BE INSTALLED.

Recall Notes:
SYSTEM: ELECTRICAL; WIRING; OTHER PART.VEHICLE DESCRIPTION: LIGHT AND MEDIUM DUTY TRUCKS, CHASSIS-CABS AND COWL-CHASSIS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UP0N SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 94V244000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: March 1st, 1994
Manufactured End Date: October 1st, 1994
Date of Owner Notification: February 10th, 1995

Defect Summary:
THE DRAG LINK INSTALLED CAN CONTACT THE FRONT AXLE I-BEAM UNDER CERTAIN EXTREME CONDITIONS. THIS DRAG LINK WAS NOT INTENDED TO BE INSTALLED ON "LOW PROFILE" VEHICLES.

Consequence Summary:
THIS CAN RESULT IN LOSS OF STEERING CONTROL.

Corrective Summary:
DEALERS WILL INSTALL THE CORRECT DRAG LINK ON THE VEHICLES.

Recall Notes:
SYSTEM: STEERING; LINKAGES; DRAG LINK.VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS WITH LOW PROFILE OPTION, 6,000 LB. OR7,000 LB. RATED FRONT AXLES.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN AREASONABLE TIME, PLEASE CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THENATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT1-800-424-9393.

---

NHTSA Campaign Number: 94V235000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: January 1st, 1994
Manufactured End Date: June 1st, 1994
Date of Owner Notification: February 10th, 1995

Defect Summary:
THE VEHICLES WERE MANUFACTURED WITHOUT SEPARATE ABS INDICATOR LAMPS. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."

Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE BRAKE SYSTEM COULD FAIL AND THE DRIVER WOULD HAVE NO WARNING.

Corrective Summary:
DEALERS WILL INSTALL ABS INDICATOR LAMP AND CIRCUITRY.

Recall Notes:
SYSTEM: BRAKES; HYDRAULIC; ANTI-SKID CONTROL MODE SOLENOID SENSOR.VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT FORD AT 1-800-424-9393. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.