2000 Ford F Super Duty Recalls

---

NHTSA Campaign Number: 00V254000
Manufacturer: FORD MOTOR COMPANY
Manufacturer Campaign Number: 00S24
Manufactured Begin Date: November 9th, 1999
Manufactured End Date: June 29th, 2000
Date of Owner Notification: September 25th, 2000

Defect Summary:
VEHICLE DESCRIPTION: MOTOR HOME CHASSIS. THESE VEHICLES MAY HAVE A MIS-ROUTED WIRE HARNESS THAT ATTACHES TO THE BRAKE PEDAL POSITION SWITCH. THE WIRE COULD RUB ON THE STEERING COLUMN, RESULTING IN A SHORT CIRCUIT AND A BLOWN FUSE, CAUSING A LOSS OF STOP LAMP FUNCTION.

Consequence Summary:
THIS WOULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND COULD LEAD TO A CRASH.

Corrective Summary:
DEALERS WILL INSPECT AND, IF NECESSARY, REPAIR THE WIRE HARNESS TO THE BRAKE PEDAL SWITCH. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 00V170000
Manufacturer: FORD MOTOR COMPANY
Manufacturer Campaign Number: 00S12
Manufactured Begin Date: November 22nd, 1999
Manufactured End Date: April 29th, 2000
Date of Owner Notification: July 27th, 2000

Defect Summary:
VEHICLE DESCRIPTION: F-SUPER DUTY STRIPPED MOTOR HOME CHASSIS BECAUSE THEY MAY HAVE A MISSING OR PARTIALLY INSTALLED BRAKE PEDAL TO MASTER CYLINDER PUSHROD RETAINING CLIP.

Consequence Summary:
IF THE CLIP IS MISSING OR FALLS OUT, THE PUSHROD COULD DISCONNECT FROM THE BRAKE PEDAL, RESULTING IN THE OPERATOR BEING UNABLE TO APPLY THE BRAKES, INCREASING THE RISK OF A CRASH.

Corrective Summary:
DEALERS WILL INSPECT THE RETAINING CLIP INSTALLATION. MISSING OR PARTIALLY INSTALLED CLIPS WILL BE PROPERLY INSTALLED. IN ADDITION, DEALERS WILL ALSO INSPECT VEHICLES FOR LOWER THAN INTENDED WHEEL LUG NUT TORQUE; INCOMPLETE TRANSMISSION SHIFT CABLE INSTALLATION; STEERING COLUMN SHIFT LEVER BRACKET BOLT TORQUE LOWER THAN INTENDED; STEERING GEAR BRACKET FASTENER TORQUE LOWER THAN INTENDED; AND LOWER STEERING COLUMN YOKE BOLT TORQUE LOWER THAN INTENDED.

Recall Notes:
OWNER NOTIFICATION BEGAN JULY 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 99V265000
Manufacturer: FORD MOTOR COMPANY
Manufacturer Campaign Number: 99S27
Manufactured Begin Date: January 2nd, 1998
Manufactured End Date: August 5th, 1999
Date of Owner Notification: October 11th, 1999

Defect Summary:
VEHICLE DESCRIPTION: SUPER DUTY TRUCKS AND CHASSIS-CABS EQUIPPED WITH 5.4L MANUAL TRANSMISSION POWERTRAINS. THE ACCELERATOR CABLE CORE WIRE CAN WEAR THE CABLE CONDUIT END FITTING DUE TO A FIFTEEN DEGREE ANGLE IT MAKES WITH THE CONDUIT AT THE THROTTLE BODY END. THIS COULD ALSO LEAD TO WEAR OR SEPARATION OF STRANDS OF THE CORE WIRE, WHICH COULD PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.

Consequence Summary:
A "STUCK" THROTTLE COULD ADVERSELY AFFECT VEHICLE CONTROL.

Corrective Summary:
DEALERS WILL REPLACE THE ACCELERATOR CABLE AND THROTTLE BODY.

Recall Notes:
OWNER NOTIFICATION BEGAN OCTOBER 11, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).