1992 Ford Escort Recalls

---

NHTSA Campaign Number: 94E019000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: December 1st, 1992
Manufactured End Date: May 1st, 1994
Date of Owner Notification: May 31st, 1994

Defect Summary:
THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.

Consequence Summary:
THIS CAN RESULT IN LOSS OF VEHICLE STEERING CONTROL ANDAN ACCIDENT.

Corrective Summary:
DANA WILL PAY FOR REPLACEMENT AND LABOR COSTS OF THE ADJUSTMENT PIN WITHOUT CHARGE TO THE INSTALLING FACILITY AND THE VEHICLE OWNER. THESE PINS SHOULD BE REPLACED BY A FORD ORIGINAL EQUIPMENT PIN ASSEMBLY. OWNER OR INSTALLER INQUIRIES CONCERNING THIS RECALL CAMPAIGN SHOULD CONTACT DANA SERVICE CENTER AT 1-800-248-9606.

Recall Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT.EQUIPMENT DESCRIPTION: OFFSET REAR TOE ADJUSTING PIN.NOTE: IF YOU HAVE ANY PROBLEMS WITH THE PIN REPLACEMENT REIMBURSEMENT PROGRAM,PLEASE CONTACT DANA SERVICE CENTER AT 1-800-248-9606. ALSO, CONTACT THENATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT1-800-424-9393.

---

NHTSA Campaign Number: 92V117000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: April 22nd, 1991
Manufactured End Date: August 30th, 1991
Date of Owner Notification: November 6th, 1992

Defect Summary:
FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.

Consequence Summary:
SHOULD A CRACK DEVELOP, FUEL VAPOR CAN ESCAPE FROM THETANK WHEN THE TANK IS FULL, AND A SMALL AMOUNT OF FUEL CAN LEAK FROM THE CRACK.FUEL LEAKS CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

Corrective Summary:
INSTALL A NEW FUEL PUMP SENDING ASSEMBLY.

Recall Notes:
SYSTEM: FUEL SYSTEM.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FUEL PUMP SENDINGASSEMBLIES PRODUCED BY FORD ELECTRICAL AND FUEL HANDLING DIVISION (FEHD).

---

NHTSA Campaign Number: 92V103000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: September 1st, 1991
Manufactured End Date: October 1st, 1991
Date of Owner Notification: September 18th, 1992

Defect Summary:
THE STOP LAMP SWITCHES COULD INTERMITTENTLY MALFUNCTION RESULTING IN THE STOP LAMPS NOT ILLUMINATING WHEN THE BRAKES ARE APPLIED.

Consequence Summary:
THIS COULD RESULT IN FOLLOWING MOTORISTS NOT BEINGSIGNALED THAT THE VEHICLE IS BRAKING, AND COULD RESULT IN A COLLISION.

Corrective Summary:
REPLACE THE FAULTY STOP LAMP SWITCHES.

Recall Notes:
SYSTEM: STOP LAMPS.VEHICLE DESCRIPTION: PASSENGER CARS.