1980 Ford E100 Recalls

---

NHTSA Campaign Number: 07E064000
Manufacturer: FORD MOTOR COMPANY
Date of Owner Notification: October 15th, 2007

Defect Summary:
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

Consequence Summary:
A LEAKING FUEL PUMP COULD CREATE A VEHICLE FIRE HAZARD.

Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CARTER, NAPA, ACCUFLOW, TRU FLOW, PARTS MASTER, AND PARTS DEPOT BRAND FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED MOTOR VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 80V120000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: May 1st, 1980
Manufactured End Date: August 1st, 1980
Date of Owner Notification: November 6th, 1980

Defect Summary:
CERTAIN VEHICLES WERE EQUIPPED WITH FRONT BRAKE HOSE ASSEMBLIES THAT WERE INCORRECTLY MANUFACTURED BY THE SUPPLIER. THESE ASSEMBLIES, BOTH RH AND LH, WERE INCORRECTLY BUILT WITH THE FITTINGS MISORIENTED BY 90 DEGREES. THIS COULD CAUSE CHAFING OF THE BRAKE HOSE THROUGH CONTACT WITH THE ADJACENT TIRE DURING FULL TURNS. CONTINUED CHAFING COULD RESULT IN A BRAKE FLUID LEAK.

Corrective Summary:
DEALER WILL INSPECT BOTH FRONT BRAKE HOSES AND, IF NECESSARY, REPLACE ONE OR BOTH HOSES AT NO CHARGE.

Recall Notes:
VEHICLE DESCRIPTION: VANS AND WAGONS.SYSTEM: SERVICE BRAKES; FRONT BRAKE HOSE ASSEMBLY.CONSEQUENCES OF DEFECT: LOSS OF BRAKE FLUID WILL CAUSE A LOSS OF FRONT WHEELBRAKING ACTION, POSSIBLY RESULTING IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: LOSS OF BRAKE FLUID MAY BE DETECTED BY ILLUMINATION OF THE BRAKE WARNINGLIGHT.

---

NHTSA Campaign Number: 80V088000
Manufacturer: FORD MOTOR COMPANY
Manufactured Begin Date: February 1st, 1980
Manufactured End Date: February 1st, 1980
Date of Owner Notification: August 29th, 1980

Defect Summary:
DUE TO COMPUTER INPUT ERROR WHICH RESULTED IN AN INCORRECT BUILD SCHEDULE, SOME VEHICLES WERE SHIPPED WITHOUT THE REQUIRED EXHAUST SYSTEM HEAT SHIELDS. WHEN THE VEHICLE IS IDLED OVER AN EXTENDED PERIOD OF TIME, A MISSING EXHAUST HEAT SHIELD MAY RESULT IN DANGEROUSLY HIGH FLOOR PAN TEMPERATURES.

Corrective Summary:
DEALER WILL INSTALL FRAME-MOUNTING HEAT SHIELDS WITHOUT CHARGE TO OWNER.

Recall Notes:
VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH 300 OR 302 CID ENGINES.SYSTEM: EXHAUST; HEAT SHIELDS.CONSEQUENCES OF DEFECT: THIS COULD RESULT IN PERSONAL INJURY TO PASSENGERS ORHEAT DAMAGE TO ITEMS STORED ON THE FLOOR OF THE VEHICLE.