2008 Diamond Coach Vip Recalls

---

NHTSA Campaign Number: 15V724000
Manufacturer: DIAMOND COACH CORPORATION
Manufactured Begin Date: January 1st, 2006
Manufactured End Date: December 31st, 2011
Date of Owner Notification: December 17th, 2015

Defect Summary:
Diamond Coach Corporation (Diamond) is recalling certain model year 2006-2011 VIP and PT 2000, 2200, 2500, 2800, 3200, and 3201 transit buses manufactured January 1, 2006, to December 31, 2011, and equipped with certain Ricon model S2010 and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence Summary:
If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Corrective Summary:
Diamond will notify owners, and owners will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 17, 2015. Owners may contact Diamond customer service at 1-620-795-2191, or Ricon Customer Service at 1-800-322-2884. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 14V611000
Manufacturer: DIAMOND COACH CORPORATION
Manufactured Begin Date: January 1st, 2006
Manufactured End Date: December 31st, 2011
Date of Owner Notification: November 19th, 2014

Defect Summary:
Diamond Coach Corporation (Diamond) is recalling certain model year 2006-2011 VIP and PT 2000, 2200, 2500, 2800, 3200, and 3201 transit buses manufactured January 1, 2006, to December 31, 2011, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence Summary:
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Corrective Summary:
Diamond will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall is expected to begin in November 2014. Owners may contact Diamond customer service at 1-800-442-4645 or Ricon customer service at 1-800-322-2884.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 12V263000
Manufacturer: DIAMOND COACH CORPORATION
Date of Owner Notification: June 25th, 2012

Defect Summary:
DIAMOND COACH CORPORATION (DIAMOND COACH) IS RECALLING CERTAIN MODEL YEAR 2008-2010 PT AND VIP BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE WHEELCHAIR LIFT?S OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Consequence Summary:
A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR?S OCCUPANT COULD FALL AND SUSTAIN INJURY.

Corrective Summary:
DIAMOND COACH IS WORKING WITH BRAUN TO IDENTIFY AND NOTIFY OWNERS, AND BRAUN DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JUNE 2012. OWNERS MAY CONTACT DIAMOND COACH AT 1-800-442-4645.

Recall Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 11V099000
Manufacturer: DIAMOND COACH CORPORATION
Manufacturer Campaign Number: CAR-11-1
Manufactured Begin Date: January 1st, 2006
Manufactured End Date: December 31st, 2010
Date of Owner Notification: February 24th, 2011

Defect Summary:
DIAMOND COACH IS RECALLING CERTAIN MODEL YEAR 2006-2010 BUSES MANUFACTURED FROM JANUARY 1, 2006 THROUGH DECEMBER 31, 2010, AND EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Consequence Summary:
IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND MAY BE ACCOMPANIED BY FLAME, SMOKE AND POTENTIAL FIRE.

Corrective Summary:
DIAMOND COACH WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 24, 2011. OWNERS MAY CONTACT CARRIER HOTLINE AT 1-800-793-4741.

Recall Notes:
DIAMOND SAFETY RECALL NO. CAR-11-1.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 10V109000
Manufacturer: DIAMOND COACH CORPORATION
Manufacturer Campaign Number: RIC-10-2
Manufactured Begin Date: May 1st, 2007
Manufactured End Date: December 1st, 2009
Date of Owner Notification: March 15th, 2010

Defect Summary:
DIAMOND COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2007-2009 VIP COACHES FITTED WITH RICON PUBLIC USE LIFTS MANUFACTURED BETWEEN DECEMBER 1, 2007 TO DECEMBER 18, 2009. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Corrective Summary:
DIAMOND COACH IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR DIAMOND COACH AT 1-800-442-4645.

Recall Notes:
DIAMOND COACH RECALL NO. RIC-10-2.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V373000
Manufacturer: DIAMOND COACH CORPORATION
Manufactured Begin Date: October 1st, 2008
Manufactured End Date: September 27th, 2009
Date of Owner Notification: October 5th, 2009

Defect Summary:
DIAMOND COACH CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 VIP TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 1, 2008 AND SEPTEMBER 27, 2009, EQUIPPED WITH CARRIER K410 ROOFTOP CONDENSERS, PART NUMBERS 77-62198-00, 77-62198-98, AND 77-62198-99. THESE K410 UNITS MAY HAVE INADEQUATE ELECTRICAL CURRENT PROTECTION SUCH THAT THE UNITS MAY OVERHEAT.

Consequence Summary:
OVERHEATING OF THE CONDENSER UNIT COULD RESULT IN A FIRE.

Corrective Summary:
DIAMOND COACH WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY AUTHORIZED CARRIER DEALERS. THE SAFETY RECALL BEGAN ON OCTOBER 5, 2009. OWNERS MAY CONTACT CARRIER AT 1-800-673-2431 OR DIAMOND COACH AT 1-620-795-2191.

Recall Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 09V201000
Manufacturer: DIAMOND COACH CORPORATION
Manufacturer Campaign Number: CAR-09
Manufactured Begin Date: November 25th, 2008
Manufactured End Date: March 23rd, 2009
Date of Owner Notification: June 11th, 2009

Defect Summary:
DIAMOND COACH IS RECALLING 10 MODEL YEAR 2008 AND 2009 VIP MOTOR COACHES MANUFACTURED BETWEEN NOVEMBER 25, 2008 AND MARCH 23, 2009, EQUIPPED WITH CARRIER K410 ROOFTOP MOUNTED CONDENSERS. THE COVER OF THE CONDENSER ASSEMBLY MAY INTERFERE WITH THE COIL HEADER WHEN THE COVER IS PLACED ON THE UNIT ASSEMBLY. THE POTENTIAL INTERFERENCE PREVENTS THE COVER FROM RESTING ON THE UNIT MOUNTING SURFACE, CREATING A GAP BETWEEN THE COVER AND UNIT ASSEMBLY.

Consequence Summary:
THIS CONDITION WILL NOT PERMIT THE COVER FASTENERS TO SECURELY CLAMP THE COVER TO THE UNIT ASSEMBLY, WHICH MAY RESULT IN THE COVER DISLOCATING FROM THE UNIT DURING OPERATION, POSSIBLY CAUSING A CRASH OR CAUSE INJURY TO PEDESTRIANS.

Corrective Summary:
DIAMOND COACH WILL REPAIR THE COACHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2009. OWNERS MAY CONTACT DIAMOND COACH TOLL-FREE AT 1-800-673-2431 EXT. 21.

Recall Notes:
DIAMOND COACH'S RECALL CAMPAIGN NO. CAR-09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .