2007 Country Coach Affinity Recalls

---

NHTSA Campaign Number: 08V484000
Manufacturer: COUNTRY COACH INC
Manufactured Begin Date: February 1st, 2005
Manufactured End Date: August 31st, 2007
Date of Owner Notification: September 28th, 2008

Defect Summary:
COUNTRY COACH IS RECALLING 238 MY 2006-2008 AFFINITY AND MAGNA MOTOR HOMES. LOSS OF POWER STEERING ASSIST CAN OCCUR IN THESE MOTOR HOMES.

Consequence Summary:
LOSS OF POWER STEERING ASSIST CAN CREATE AN UNSAFE DRIVING CONDITION WHICH COULD RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL REPLACE THE FAN DRIVE HYDRAULIC PUMP AND THE TRANSMISSION MOUNTED DRY SPLINE POWER TAKE-OFF WITH A WET SPLINE POWER TAKE-OFF AND RELOCATE THE ENGINE POWER STEERING PUMP TO THE ENGINE POWER STEERING MECHANICAL DRIVE PAD. OWNERS WILL BE NOTIFIED ABOUT THIS RECALL BEGINNING ON SEPTEMBER 28, 2008, WITH INSTRUCTIONS THAT SHOULD THEY EXPERIENCE LOSS OF POWER STEERING OR A SEVERE REDUCTION IN THE ABILITY TO STEER THE MOTOR HOME THAT THEY SHOULD IMMEDIATELY CONTACT THE COUNTRY COACH SERVICE CENTER. THE PARTS NECESSARY FOR THIS RECALL WILL NOT BE AVAILABLE UNTIL MID-NOVEMBER 2008, AT WHICH TIME THE OWNERS WILL BE NOTIFIED TO BRING IN THEIR VEHICLE FOR REPAIR. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

Recall Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 08V119000
Manufacturer: COUNTRY COACH INC
Manufactured Begin Date: February 1st, 2006
Manufactured End Date: February 28th, 2007
Date of Owner Notification: June 17th, 2008

Defect Summary:
COUNTRY COACH IS RECALLING 1,228 MY 2004-2008 MAGNA, AFFINITY AND INTRIGUE MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUES SPECIFIED IN FMVSS NO. 108.

Consequence Summary:
INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A MOTOR VEHICLE CRASH.

Corrective Summary:
DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE OF EACH MOTOR HOME AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 06V329000
Manufacturer: COUNTRY COACH INC
Manufactured Begin Date: February 1st, 2006
Manufactured End Date: August 31st, 2006
Date of Owner Notification: September 18th, 2006

Defect Summary:
ON CERTAIN MOTOR HOMES, EXISTING FASTENERS USED TO SECURE THE SATELLITE DOME TO THE MOTOR HOME ROOF DO NOT PENETRATE THE ROOF SUFFICIENTLY TO PREVENT THE DOME FROM COMING OFF WHILE THE VEHICLE IS IN TRANSIT.

Consequence Summary:
THE SATELLITE DOME COULD SEPARATE FROM THE ROOF WHILE DRIVING INCREASING THE SAFETY HAZARD TO TRAFFIC.

Corrective Summary:
DEALERS WILL REPLACE THE EXISTING FASTENER WITH A JACK NUT AND LONGER BOLTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 18, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-452-8015.

Recall Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.