2001 Coachmen Catalina Recalls

---

NHTSA Campaign Number: 03V373000
Manufacturer: COACHMEN INDUSTRIES, INC.
Manufactured Begin Date: May 1st, 2000
Manufactured End Date: December 11th, 2002

Defect Summary:
ON CERTAIN MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence Summary:
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Corrective Summary:
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR COACHMEN AT 1-219-825-5821.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V132000
Manufacturer: COACHMEN INDUSTRIES, INC.
Manufactured Begin Date: November 3rd, 2000
Manufactured End Date: March 29th, 2001
Date of Owner Notification: May 18th, 2001

Defect Summary:
VEHICLE DESCRIPTION: TRAVEL TRAILERS. THE WRONG LOAD RANGE TIRES WERE INADVERTENTLY INSTALLED. AFFECTED UNITS WILL HAVE LOAD RANGE "B" TIRES INSTEAD OF THE REQUIRED LOAD RANGE "C" TIRES.

Consequence Summary:
IF THE TRAVEL TRAILER WAS LOADED TO A WEIGHT THAT EXCEEDED THE CAPACITY OF THE TIRES, A TIRE FAILURE COULD OCCUR, RESULTING IN A LOSS OF CONTROL.

Corrective Summary:
DEALERS WILL INSTALL LOAD RANGE "C" TIRES ON AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN MAY 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 00V337000
Manufacturer: COACHMEN INDUSTRIES, INC.
Manufactured Begin Date: August 8th, 2000
Manufactured End Date: October 13th, 2000
Date of Owner Notification: October 30th, 2000

Defect Summary:
VEHICLE DESCRIPTION: TRAVEL TRAILERS EQUIPPED WITH DROP AXLES AND 13" WHEELS. INCORRECT AXLE AND WHEEL ASSEMBLIES WERE INSTALLED. THE UNLOADED VEHICLE WEIGHT MAY EXCEED THE CARRYING CAPACITY OF THE TIRES.

Consequence Summary:
THIS COULD CAUSE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING, LEADING TO A LOSS OF STEERING CONTROL.

Corrective Summary:
DEALERS WILL REPLACE THE AXLE ASSEMBLIES AND WHEELS.

Recall Notes:
OWNER NOTIFICATION BEGAN OCTOBER 30, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-800-453-6064. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).