2000 Coachmen Catalina Recalls

---

NHTSA Campaign Number: 03V373000
Manufacturer: COACHMEN RV COMPANY, LLC
Manufactured Begin Date: May 1st, 2000
Manufactured End Date: December 11th, 2002

Defect Summary:
ON CERTAIN MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence Summary:
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Corrective Summary:
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR COACHMEN AT 1-219-825-5821.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 02V012000
Manufacturer: COACHMEN RV COMPANY, LLC
Manufactured Begin Date: October 1st, 1998
Manufactured End Date: May 31st, 2000
Date of Owner Notification: January 23rd, 2002

Defect Summary:
ON CERTAIN REAR DIESEL MOTOR HOMES EQUIPPED WITH OPTIONAL GAS GENERATORS, THE GENERATOR FUEL FILL GAS CAP PROVIDED WITH THE UNIT MAY NOT COMPLETELY SEAL AGAINST THE RIM OF THE FILL TUBE.

Consequence Summary:
THIS COULD ALLOW ANY GAS THAT IS SPLASHED AGAINST THE CAP DURING VEHICLE OPERATION, SUDDEN STOPS, OR TURNS, OR A CRASH, TO LEAK OUT. IF GAS IS ALLOWED TO LEAK OUT THROUGH THE UNSEALED CAP/FILL CONNECTION, THE POTENTIAL FOR A FIRE EXISTS.

Corrective Summary:
DEALERS WILL REPLACE THE GENERATOR FUEL FILL TUBE AND CAP ASSEMBLY. OWNER NOTIFICATION BEGAN JANUARY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-800-453-6064.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 00V273001
Manufacturer: COACHMEN RV COMPANY, LLC
Manufactured Begin Date: January 21st, 2000
Manufactured End Date: September 11th, 2000

Defect Summary:
VEHICLE DESCRIPTION: CLASS A AND C MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

Consequence Summary:
SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

Corrective Summary:
AM-SAFE IN NOTIFYING CUSTOMERS THAT THEY WILL INSPECT AND REPLACE THE DEFECTIVE BUCKLE ASSEMBLIES FREE OF CHARGE.

Recall Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 00V265001
Manufacturer: COACHMEN RV COMPANY, LLC

Defect Summary:
VEHICLE DESCRIPTION: TRAVEL TRAILERS AND FIFTH WHEEL VEHICLES EQUIPPED WITH TEKONSHA OR BARGMAN BREAKAWAY SWITCH ASSEMBLIES. THE SUBJECT SWITCHES ARE BASE PARTS 2011 AND 50-85-009, AND ARE BRANDED TEKONSHA (2011) AND BARGMAN (50-85-009). THESE MAY BE PACKAGED IN KIT NUMBERS 1026, 1028, 2011-23, 2028-23, 2011P, 2011AP, 20005, 20010, 20015, 20020, 2026, 2026-LB, 2028, 1026-LB, 50-85-200, 50-85-201, 50-85-250, 5061404, 5061406, 5061407, 5061408, 5061410, 5061506, 5061507, 5061508, 5067406, 5067407, 5067408, 5067409, AND 5067410. THE INTERNAL SWITCHING MECHANISM MAY FAIL TO MAKE PROPER CONTACT AND PROVIDE ELECTRICAL CONTINUITY WHEN THE BREAKAWAY PIN IS PULLED. THIS CONDITION MAY RESULT IN NO ELECTRICAL POWER TO THE TRAILER BRAKES IN THE EVENT OF A TRAILER BREAKAWAY SITUATION AND COULD OCCUR WITHOUT WARNING.

Consequence Summary:
IN THE EVENT OF A TRAILER BREAKING LOOSE FROM A TOW VEHICLE, THE MALFUNCTION OF A BREAKAWAY SWITCH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, PROPERTY DAMAGE OR BOTH.

Corrective Summary:
TEKONSHA IS NOTIFYING DISTRIBUTORS AND ORIGINAL EQUPIMENT MANUFACTURERS AND WILL REPLACE THE DEFECTIVE BREAKAWAY DEVICE WITH NEW BREAKAWAY KITS FREE OF CHARGE. ALSO, TEKONSHA WILL REIMBURSE FOR ALL FREIGHT CHARGES TO AND FROM ITS CUSTOMERS ON RECALLED PART NUMBER.

Recall Notes:
TEKONSHA STARTED NOTIFYING OWNERS DURING SEPTEMBER 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TEKONSHA TOWING SYSTEMS AT 1-800-325-5860 OR COACHMEN AT 1-219-825-5821.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).