2002 Chevrolet Trailblazer Recalls

---

NHTSA Campaign Number: 06E025000
Manufacturer: GENERAL MOTORS LLC
Date of Owner Notification: May 2nd, 2006

Defect Summary:
CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Corrective Summary:
POLI-AUTO WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE HEADLAMPS AT ITS ORIGINAL PURCHASE PRICE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT POLI-AUTO AT 305-477-1356.

Recall Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 04V527000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 4087
Manufactured Begin Date: October 1st, 2000
Manufactured End Date: June 30th, 2002
Date of Owner Notification: November 22nd, 2004

Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.

Consequence Summary:
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.

Corrective Summary:
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.

Recall Notes:
GM RECALL NO. 04087. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 04V201000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 4037
Manufactured Begin Date: October 1st, 2000
Manufactured End Date: January 31st, 2002
Date of Owner Notification: June 24th, 2004

Defect Summary:
CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS EXTRACTED DURING A CRASH; HOWEVER, THE MECHANISM THAT LOCKS THE SEAT BELT RETRACTOR WHEN THE VEHICLE DECELERATES QUICKLY, SUCH AS HEAVY BRAKING, MAY NOT OPERATE AS INTENDED.

Consequence Summary:
IF THIS WERE TO OCCUR, THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, AND COULD RESULT IN INJURY TO THE OCCUPANT.

Corrective Summary:
DEALERS WILL INSPECT THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTORS, AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 24, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537.

Recall Notes:
GM RECALL NO. 04037.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 04V046000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 4005
Manufactured Begin Date: October 1st, 2000
Manufactured End Date: June 30th, 2002
Date of Owner Notification: July 6th, 2004

Defect Summary:
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.

Consequence Summary:
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.

Recall Notes:
GM RECALL NO. 04005.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V250000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 3039
Manufactured Begin Date: October 1st, 2000
Manufactured End Date: June 30th, 2002
Date of Owner Notification: August 20th, 2003

Defect Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Corrective Summary:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Recall Notes:
GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V096000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 3013
Manufactured Begin Date: October 1st, 2000
Manufactured End Date: March 31st, 2003
Date of Owner Notification: May 29th, 2003

Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION" AND NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE AN INTERMITTENT CONDITION DURING VEHICLE START-UP IN WHICH THE INSTRUMENT PANEL CLUSTER MAY NOT PROPERLY POWER UP, RESULTING IN MOST OF THE DISPLAYS, TELLTALE LIGHTS, AND FUNCTIONS (EXCEPT THE SERVICE ENGINE LIGHT, TURN SIGNAL INDICATORS, AND THE INSTRUMENT PANEL CLUSTER BACKLIGHTING) BEING INOPERATIVE.

Consequence Summary:
THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.

Corrective Summary:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER. OWNER NOTIFICATION BEGAN MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.

Recall Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V075000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 3012
Manufactured Begin Date: October 1st, 2000
Manufactured End Date: June 30th, 2002
Date of Owner Notification: May 29th, 2003

Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.

Consequence Summary:
THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.

Corrective Summary:
DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.

Recall Notes:
GM RECALL NO. 03012. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 02V273000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 2045
Manufactured Begin Date: February 1st, 2002
Manufactured End Date: September 30th, 2002
Date of Owner Notification: October 4th, 2002

Defect Summary:
CERTAIN SPORT UTILITY VEHICLES ARE MISSING WELDS ON THE REAR FLOOR PLAN.

Consequence Summary:
IN A CRASH, MISSING WELDS COULD DEGRADE PERFORMANCE OF THE THIRD ROW SEAT AND SAFETY BELT ANCHORAGE AND OCCUPANTS COULD RECEIVE GREATER INJURIES.

Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF MISSING WELDS ARE FOUND, GM WILL EXCHANGE THE VEHICLE FOR AN EQUIVALENT VEHICLE OR PROVIDE A REFUND OF THE PURCHASE PRICE. OWNER NOTIFICATION BEGAN OCTOBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Recall Notes:
GM RECALL NO. 02045.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 02V121000
Manufacturer: GENERAL MOTORS LLC
Manufactured Begin Date: September 1st, 2001
Manufactured End Date: February 28th, 2002
Date of Owner Notification: September 20th, 2002

Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, A FUEL FILTER FITTING CAN BECOME DISCONNECTED. IF THIS WERE TO OCCUR WHILE ATTEMPTING TO START THE ENGINE, A NO-START CONDITION WOULD RESULT AND FUEL WOULD BE PUMPED OUT THE FUEL FILTER ONTO THE GROUND.

Consequence Summary:
IF THE FITTING BECOMES DISCONNECTED WHILE THE VEHICLE IS IN MOTION, THE ENGINE WOULD STOP DUE TO INADEQUATE FUEL SUPPLY AND CAUSE A LOSS OF POWER STEERING ASSIST. IF AN IGNITION SOURCE WERE PRESENT, FUEL LEAKAGE FROM A DISCONNECTED FUEL FILTER FITTING COULD RESULT IN A FIRE.

Corrective Summary:
DEALERS WILL REPLACE THE FUEL FILTER QUICK CONNECT RETAINERS. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 02V222000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 2032
Manufactured Begin Date: May 1st, 2002
Manufactured End Date: July 31st, 2002
Date of Owner Notification: August 15th, 2002

Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Recall Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V334000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 01064/01065
Manufactured Begin Date: January 1st, 2001
Manufactured End Date: August 31st, 2001
Date of Owner Notification: November 6th, 2001

Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.

Consequence Summary:
IF THE GEAR IS NOT ENGAGED, THE VEHICLE CAN ROLL WHEN THE TRANSMISSION IS IN "PARK" AND A CRASH COULD RESULT WITHOUT WARNING.

Corrective Summary:
DEALERS WILL UPDATE THE TRANSFER CASE CONTROL MODULE CALIBRATION TO INCREASE GEAR ENGAGEMENT. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V283000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 1061
Manufactured Begin Date: August 1st, 2001
Manufactured End Date: August 28th, 2001
Date of Owner Notification: September 6th, 2001

Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.

Consequence Summary:
THIS CONDITION COULD RESULT IN A COMPLETE FRACTURE OF THE RANGE SHIFT COLLAR AND SUBSEQUENT LOSS OF VEHICLE FORWARD AND REVERSE GEARS, AND THE INABILITY TO MAINTAIN "PARK" POSITION. THIS INCREASES THE RISK OF A VEHICLE CRASH RESULTING FROM UNINTENDED MOVEMENT OF A PARKED VEHICLE.

Corrective Summary:
DEALERS WILL REPLACE THE TRANSFER CASES AND UPDATE THE CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 01V126000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 1034
Manufactured Begin Date: July 1st, 1999
Manufactured End Date: July 31st, 1999
Date of Owner Notification: April 4th, 2001

Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.

Consequence Summary:
A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, RESULTING IN A CRASH.

Corrective Summary:
DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CONTROL ARM BRACKETS. OWNER NOTIFICATION BEGAN BY TELEPHONE ON APRIL 4, 2001. THE FOLLOWUP LETTER TO CONSUMERS WAS MAILED MAY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.

Recall Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).