1990 Chevrolet Suburban Recalls

---

NHTSA Campaign Number: 06E043000
Manufacturer: GENERAL MOTORS LLC
Date of Owner Notification: October 18th, 2006

Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 93V187000
Manufacturer: GENERAL MOTORS LLC
Manufactured Begin Date: August 1st, 1984
Manufactured End Date: January 1st, 1991
Date of Owner Notification: January 20th, 1994

Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.

Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.

Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.

Recall Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 93V119000
Manufacturer: GENERAL MOTORS LLC
Date of Owner Notification: November 8th, 1993

Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.

Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.

Recall Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 93V016000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 93-C-07
Manufactured Begin Date: December 1st, 1986
Manufactured End Date: August 1st, 1992
Date of Owner Notification: March 13th, 1993

Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.

Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.

Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.

Recall Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.