1992 Chevrolet C10 Recalls

---

NHTSA Campaign Number: 09E012000
Manufacturer: GENERAL MOTORS LLC
Date of Owner Notification: May 11th, 2009

Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 99V130000
Manufacturer: GENERAL MOTORS LLC
Manufactured Begin Date: August 1st, 1991
Manufactured End Date: July 31st, 1992
Date of Owner Notification: June 29th, 1999

Defect Summary:
VEHICLE DESCRIPTION: EXTENDED-CAB PICKUP TRUCKS EQUIPPED WITH HIGH-BACK BUCKET SEATS. THE SEAT RECLINER TO FRAME ATTACHING BOLTS CAN LOOSEN, FATIGUE, AND FRACTURE ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.

Consequence Summary:
IF THIS WERE TO OCCUR TO THE DRIVER'S SEAT, THIS COULD RESULT IN A SUDDEN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Corrective Summary:
DEALERS WILL REMOVE ALL FOAM AND/OR FABRIC SANDWICHED BETWEEN THE RECLINER ASSEMBLY AND THE SEAT FRAME, INSTALL WASHERS BETWEEN THE SEAT RECLINER AND THE SEAT FRAME AT EACH ATTACHMENT POINT, AND INSTALL NEW ATTACHING BOLTS TORQUED TO A HIGHER SPECIFICATION.

Recall Notes:
OWNER NOTIFICATION BEGAN JUNE 29, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 94V044001
Manufacturer: GENERAL MOTORS LLC
Manufactured Begin Date: October 1st, 1991
Manufactured End Date: January 1st, 1993
Date of Owner Notification: March 30th, 1994

Defect Summary:
VEHICLES ALTERED BY PAS, INC. HAVE COMPRESSED NATURAL GAS FUEL TANKS THAT CAN DEVELOP STRESS CORROSION, WHICH CRACK THE E-GLASS WRAPPING. THIS STRESS CORROSION CRACKING CAN LEAD TO TANK RUPTURES.

Consequence Summary:
IF THE TANK RUPTURES, PERSONAL INJURY TO INDIVIDUALS IN OR NEAR THE VEHICLE MAY OCCUR.

Corrective Summary:
GM IS OFFERING TO EXCHANGE THESE VEHICLES WITH A COMPARABLY EQUIPPED 1994 GASOLINE 1/2 OR 3/4 TON GM PICKUP. IF THE OWNER CHOOSES NOT TO EXCHANGE THE NATURAL GAS VEHICLE, GM WILL REPURCHASE THE VEHICLE.

Recall Notes:
SYSTEM: FUEL; CNG; TANKS.VEHICLE DESCRIPTION: LIGHT, 2 WHEEL DRIVE PICKUP TRUCKS EQUIPPED TO RUN ON COMPRESSED NATURAL GAS.WARNING: ALL TRUCKS SHOULD BE REMOVED FROM SERVICE AND THE ENGINE RUN UNTIL THE GAS GAUGE READS BELOW ONE-QUARTER TANK. NO INSPECTION SHOULD BE UNDERTAKEN.CONTACT GENERAL MOTORS AT THE TELEPHONE NUMBER BELOW FOR MORE DETAILED INFORMATION.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT GENERAL MOTORS CONSOLIDATED FLEET SERVICE OPERATIONS (CHEVROLET) AT1-800-334-7000, OR CONTACT GMC TRUCK AT 1-800-462-7000. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 93V016000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 93-C-07
Manufactured Begin Date: December 1st, 1986
Manufactured End Date: August 1st, 1992
Date of Owner Notification: March 13th, 1993

Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.

Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.

Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.

Recall Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.