2007 Chevrolet Aveo Recalls

---

NHTSA Campaign Number: 14V261000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 14093, 14236
Manufactured Begin Date: September 27th, 2003
Manufactured End Date: March 25th, 2004
Date of Owner Notification: February 6th, 2015

Defect Summary:
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

Consequence Summary:
If the DRL module melts due to the heat generation, it could cause a vehicle fire.

Corrective Summary:
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

Recall Notes:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

---

NHTSA Campaign Number: 06V398000
Manufacturer: GENERAL MOTORS LLC
Manufacturer Campaign Number: 6133
Manufactured Begin Date: December 1st, 2005
Manufactured End Date: September 30th, 2006
Date of Owner Notification: November 16th, 2006

Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.

Consequence Summary:
IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.

Corrective Summary:
DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Recall Notes:
GM RECALL NO. 06133. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.