1995 Bmw 740i Recalls

---

NHTSA Campaign Number: 10E021000
Manufacturer: BMW OF NORTH AMERICA, LLC
Date of Owner Notification: May 28th, 2010

Defect Summary:
FCP GROTON IS RECALLING CERTAIN STEERING CENTER DRAG LINKS, P/N 32 21 1 096 057, SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AS REPLACEMENT EQUIPMENT FOR MODEL YEAR 1995 THROUGH 2001 BMW 740I, 740IL, AND 750IL PASSENGER VEHICLES. THE SHAFT OF THE STEERING CENTER TIE ROD MAY SHEAR OFF.

Consequence Summary:
THIS CONDITION WOULD RESULT, WITHOUT WARNING, IN IMMEDIATE AND COMPLETE LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.

Corrective Summary:
FCP GROTON WILL NOTIFY OWNERS AND THE TIE ROD WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 1, 2010. OWNERS MAY CONTACT FCP GROTON TOLL-FREE AT 1-877-634-0063.

Recall Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FCP GROTON STEERING CENTER DRAG LINKS BEARING P/N 32 21 1 096 057 SOLD FROM DECEMBER 1, 2009 THROUGH APRIL 9, 2010 AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON ANY VEHICLES MANUFACTURED BY BMW.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

---

NHTSA Campaign Number: 97V140000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufactured Begin Date: September 1st, 1994
Manufactured End Date: August 30th, 1996
Date of Owner Notification: October 30th, 1997

Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.

Consequence Summary:
THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.

Corrective Summary:
DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.

Recall Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 97V131000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufactured Begin Date: June 1st, 1992
Manufactured End Date: July 30th, 1997
Date of Owner Notification: October 30th, 1997

Defect Summary:
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.

Consequence Summary:
THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.

Corrective Summary:
DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Recall Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V238000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufactured Begin Date: September 1st, 1994
Manufactured End Date: October 1st, 1995
Date of Owner Notification: January 5th, 1996

Defect Summary:
FUEL SEEPAGE CAN OCCUR BETWEEN A HOSE AND THE METAL FUEL LINE ON EITHER END OF THE HOSE RESULTING IN FUEL ODOR.

Consequence Summary:
FUEL LEAKAGE COULD POTENTIALLY RESULT IN A VEHICLE FIRE.

Corrective Summary:
DEALERS WILL REPLACE THE TWO FUEL HOSES, FOUR METAL FUEL LINES AND ASSOCIATED CLAMPS.

Recall Notes:
SYSTEM: FUEL; FUEL LINES; HOSES; NON-METALLIC.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

---

NHTSA Campaign Number: 95V192000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufactured Begin Date: March 1st, 1995
Manufactured End Date: May 1st, 1995
Date of Owner Notification: January 5th, 1996

Defect Summary:
THE LOWER SUSPENSION ARM MOUNTING EYE ON THE RIGHT SIDE REAR AXLE HUB CARRIER WAS PRODUCED WITH A CASTING FLAW.

Consequence Summary:
IT IS POSSIBLE THAT THE RIGHT SIDE REAR AXLE CARRIER EYE COULD CRACK AND BREAK WHILE DRIVING CAUSING A LOSS OF CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Corrective Summary:
DEALERS WILL INSPECT THE VEHICLES FOR A CASTING FLAW IN THE RIGHT SIDE REAR AXLE CARRIER AND IF FOUND, REPLACE THE CARRIER.

Recall Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.