1999 Bmw 328i Recalls

---

NHTSA Campaign Number: 02V223000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufacturer Campaign Number: E46
Manufactured Begin Date: April 8th, 1999
Manufactured End Date: August 31st, 1999
Date of Owner Notification: October 25th, 2002

Defect Summary:
ON CERTAIN 4-DOOR PASSENGER VEHICLES, THE SIDE AIR BAG SYSTEM COULD DEPLOY IN CERTAIN NON-CRASH IMPACTS, SUCH AS WHEN CONTACTING LARGE POTHOLES OR CURBS AT SUBSTANTIAL SPEEDS.

Consequence Summary:
THIS COULD CAUSE THE SIDE AIR BAG AND HEAD PROTECTION SYSTEM TO DEPLOY WITHOUT AN ACTUAL SIDE CRASH OR IMPACT SEVERE ENOUGH TO CAUSE SIGNIFICANT VISIBLE DAMAGE TO THE VEHICLE. UNEXPECTED DEPLOYMENT OF THE SIDE AIR BAG COULD CAUSE SERIOUS INJURY IF THE OCCUPANT'S HEAD IS RESTING NEAR THE SIDE AIR BAG.

Corrective Summary:
DEALERS WILL RECALIBRATE THE CENTRAL AIR BAG CONTROL MODULE TO REDUCE THE POSSIBILITY OF SUCH A NON-CRASH DEPLOYMENT. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.

Recall Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 99V100000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufactured Begin Date: June 1st, 1998
Manufactured End Date: March 8th, 1999
Date of Owner Notification: May 14th, 1999

Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IT IS POSSIBLE THAT THE RETAINING CLIP THAT SECURES THE BRAKE BOOSTER PUSHROD TO THE BRAKE PEDAL ARM WAS NOT PROPERLY INSTALLED DURING PRODUCTION. IT IS POSSIBLE FOR THE CLIP TO DETACH FROM THE PIN ON THE BRAKE PEDAL ARM ALLOWING THE PUSHROD TO DISCONNECT FROM THE ARM.

Consequence Summary:
IF THIS OCCURS, BRAKING IS NOT POSSIBLE.

Corrective Summary:
DEALERS WILL INSPECT THE CLIP FOR TIGHT INSTALLATION AND REPLACE THE CLIP IF IT IS LOOSE.

Recall Notes:
OWNER NOTIFICATION BEGAN MAY 14, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 99V063000
Manufacturer: BMW OF NORTH AMERICA, LLC
Manufactured Begin Date: June 1st, 1998
Manufactured End Date: March 25th, 1999
Date of Owner Notification: April 30th, 1999

Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES ARE BUILT WITH A SIDE AIR BAG SYSTEM CONSISTING OF DOOR-MOUNTED THORAX AIR BAGS (REAR DOOR AIR BAGS ARE OPTIONAL), A HEAD PROTECTION SYSTEM (HPS) FOR FRONT OCCUPANTS, A CENTRAL ELECTRONIC SENSOR AND DIAGNOSTIC SYSTEM, LEFT AND RIGHT SATELLITE IMPACT SENSORS, AND ASSOCIATED WIRING. THIS SYSTEM IS UNDULY SENSITIVE TO CERTAIN NON-CRASH IMPACTS, SUCH AS CONTACTING LARGE POTHOLES OR CURBS AT SUBSTANTIAL SPEED.

Consequence Summary:
THIS COULD CAUSE THE SIDE AIR BAG AND HPS TO DEPLOY WITHOUT AN ACTUAL SIDE CRASH. IN ADDITION, THE BATTERY SAFETY TERMINAL (BST) WOULD ALSO ACTIVATE, DISCONNECTING THE STARTER CABLE FROM THE BATTERY. IN THIS CASE, VEHICLE ELECTRICAL SYSTEM WOULD CONTINUE TO OPERATE AND THE ENGINE WOULD CONTINUE TO RUN, BUT AFTER STOPPING, COULD NOT BE RESTARTED.

Corrective Summary:
DEALERS WILL REPROGRAM THE CENTRAL COMPUTER CONTROL MODULE THAT REGULATES THE PERFORMANCE OF ALL OF THE VEHICLE'S OCCUPANT PROTECTION SYSTEMS.

Recall Notes:
OWNER NOTIFICATION BEGAN APRIL 30, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).