2003 Autocar Wxr Recalls

---

NHTSA Campaign Number: 05V295000
Manufacturer: AUTOCAR, LLC
Manufacturer Campaign Number: A-0402-A
Manufactured Begin Date: July 23rd, 2003
Manufactured End Date: May 31st, 2005
Date of Owner Notification: October 19th, 2004

Defect Summary:
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE BACKUP ALARM MOTION SENSOR MAY NOT HAVE BEEN INSTALLED CORRECTLY AND MAY NOT SENSE WHEN THE VEHICLE MOVERS BACKWARDS UNDER ANY CIRCUMSTANCES.

Consequence Summary:
THE VEHICLE MAY ROLL BACKWARDS WITHOUT THE BACKUP ALARM SOUNDING WITH THE RISK OF RUNNING OVER OR CRUSHING A PERSON STANDING OR WORKING BEHIND THE VEHICLE.

Corrective Summary:
DEALERS WILL REPOSITION THE MOTION SENSOR IN RELATION TO THE MAGNETS THAT ROTATE WHEN THE VEHICLE MOVES. THE RECALL BEGAN ON OCTOBER 19, 2004. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486.

Recall Notes:
AUTO RECALL NO.A-0402-A.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 05V032000
Manufacturer: AUTOCAR, LLC
Manufacturer Campaign Number: A-0501
Manufactured Begin Date: July 1st, 2003
Manufactured End Date: December 31st, 2004
Date of Owner Notification: February 11th, 2005

Defect Summary:
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH BENDIX AUTOMATIC BRAKE SYSTEMS (ABS), THE BRAKES MAY HAVE A SYSTEM FAULT THAT MAY NOT BE DETECTED BY THE ABS ELECTRONIC CONTROL UUNIT (ECU) AND THEREFORE WILL NOT GENERATE AN ABS WARNING LIGHT ON THE DASH OF THE TRUCK.

Consequence Summary:
THE ABS BRAKES MAY NOT PERFORM AS DESIGNED AND IN AN ABS ASSISTED STOP THE DRIVER MAY NOT BE ABLE TO MAINTAIN STEERING CONTROL OF THE VEHICLE. WHEN VEHICLE CONTROL IS COMPROMISED THERE IS A CHANCE FOR A CRASH.

Corrective Summary:
DEALERS WILL INSPECT, RESET AND CHECK THE ECU FOR FAULT LIGHTS AND CHECK THE ABS BRAKES FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 11, 2005. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486.

Recall Notes:
AUTOCAR RECALL NO. A-0501.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

---

NHTSA Campaign Number: 04V390000
Manufacturer: AUTOCAR, LLC
Manufacturer Campaign Number: A-0401
Manufactured Begin Date: December 9th, 2003
Manufactured End Date: July 20th, 2004
Date of Owner Notification: September 3rd, 2004

Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH ACCURIDE 22.5 X 9.00 - HUB PILOT H.D. STEEL WHEEL RIMS, THE REAR AXLE WHEEL STUDS ARE TOO SHORT. THESE STUDS MAY NOT BE ABLE TO RETAIN THE WHEEL NUT TORQUE AND COULD LOOSEN ALLOWING THE LOSS OF A WHEEL.

Consequence Summary:
IF A VEHICLE LOSES A WHEEL WHILE TRAVELING DOWN A ROADWAY, A CRASH COULD OCCUR, PROPERTY DAMAGE TO FOLLOWING VEHICLES OR PERSONAL INJURY TO PERSONS OUTSIDE THE VEHICLE.

Corrective Summary:
DEALERS WILL REPLACE THE REAR AXLE WHEEL STUDS. THE RECALL BEGAN ON SEPTEMBER 3, 2004. OWNERS SHOULD CONTACT AUTOCAR AT 1-877-973-3486.

Recall Notes:
AUTOCAR RECALL NO.A-0401.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

---

NHTSA Campaign Number: 03V493000
Manufacturer: AUTOCAR, LLC
Manufacturer Campaign Number: A-0307
Manufactured Begin Date: January 14th, 2002
Manufactured End Date: November 18th, 2003
Date of Owner Notification: December 15th, 2003

Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH ALLISON HEAVY DUTY TRANSMISSIONS, THE BOLTS FASTENING THE PROPSHAFT TO THE TRANSMISSION YOKE WERE NOT TIGHTENED SUFFICIENTLY. LOOSE BOLTS CAN CAUSE DISLOCATION OF THE PROPSHAFT.

Consequence Summary:
THIS CONDITION COULD CAUSE THE VEHICLE TO LOSE POWER TO ITS WHEELS AND RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL INSPECT AND RE-TIGHTEN BOLTS TO THE REQUIRED SPECIFICATIONS . CUSTOMERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUTOCAR AT 1-765-489-5499.

Recall Notes:
AUTOCAR RECALL NO. A-0307.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).